14. Slump cone to be filled
\/1a) 3 layers 25 strokes 4 layers 25 strokes c) 4 layers 35 strokes
15. Concrete cube moulds to be fill in
R23 layers 3 layers 35 strokes _c) 3 layers and not less than 35 strokes
YA 16. Concrete cube to be tested at a load of kg/em? per minute
a) 130 140 c) 310
17, Concrete for pumping should be
2S cohesive b) over sanded c) with higher slump
18.Concrete used for bored. cast in situ pile should have a slump of
1 a) 100 to 150 mm 150to 180mm —c)_ 160 to 200 mm
19. Water addition at site to concrete mix will have
/! @) Increased strength and workability ‘increased workability decreased strength
20. Sand used for concrete should have a FM range of
92.0 03.2 b) 2.61032 H1B to 2.8
21. Crushed sand used for concrete can have in 150 microns
i a) Passing of 20 % Passing of 15 % c) Passing of 10 %
22. Minimum cement content & Maximum w/c ratio for Moderate Exposure condition
as per IS 456
/7a) 3200.50 b¥300, 0.50 c) 360, 0.55
23, Minimum grade of concrete in Severe environment conditions
x M35 b) M40 c) M30
24,ps per IS 1489 PPC cement has fly ash content of
V7 BF 15 to 35 % b) Oto 25% c) 25 %
" 25. IS code for Portland slag cement
a) Is 456 _ UBS IS 455 c) IS 457
26. Which determines conggete strength
18) Cement strength Deaie ratio c) cement / water ratio -
27. Vibration in.a place after insertion of needle to be done for __ seconds
Yu 2) 307 WF 10to15 —c) 20 sec max
28 Allowable variation in individual cube strength from average strength _______. %
Say 5% b) 10% 15 %
29. Flakiness & Elongation Index limit as per IS 383
shar 25% 30% c) Not specified
30. Grading zone of fine aggregate is determined based on
_/7) Limit specified as per IS 383 1p7600 microns c) 150 microns