Professional Documents
Culture Documents
NIT-EN Quick Start Guide Front Panel Indicators and Controls
NIT-EN Quick Start Guide Front Panel Indicators and Controls
Name
Type
Function
PWR
Green LED
TD
Amber LED
RD
Amber LED
LOS
Red LED
AIS
Amber LED
LINE
Red LED
PASS
Green LED
TEST
Green LED
ANA
Pushbutton
Causes the local NIT-EN to loop its transmitter output back to its receiver. The transmitter
DIG
Pushbutton
Causes the local NIT-EN to loop received data to its transmitter. Data Set Ready changes to OFF.
REM
Pushbutton
Not used.
PATT
Pushbutton
The PATT switch causes NIT-EN to send and receive a 511 test pattern. If test is successful, the
PASS indicator lights up.
2 Switches
JP
JP
state
Jump to GND
JP1
Jump to FG
JP2=OFF
JP3=ON
JP2/JP3
JP2=ON
JP3=OFF
SW
SW5
protective ground
DIP2
Jump to FG
75
75
Console cable
sequence of
CISCO
reserved
75
120
DIP1
Jump to FG
protective ground
2-3 CLOSE
STATE
NIT-EN/C
DIP
NIT-EN
Signal ground is not connected to the
1-2 CLOSE
JP4/JP5
Factory setting
function
Factory setting
Function
ON
Software control
OFF
Firmware control
ON
local
OFF
remote
ON
V.35 interface
reserved
NIT-EN
NIT-EN/C
OFF
OFF
OFF
ON
ON
ON
OFF
DIP3
DIP4=ON
DIP5=ON
DIP4=ON
DIP5=OFF
DIP4=OFF
DIP5=OFF
DIP6
DIP7
DIP8
E1/FE1 interface
Internal
Receive
DIP4=ON
DIP5=OFF
DIP4=OFF
DIP5=OFF
External
ON
OFF
ON
OFF
ON
OFF
OFF
OFF
OFF
OFF
OFF
OFF