Professional Documents
Culture Documents
Application of Communication and Remote Control in PLC Based On ZigBee Technology
Application of Communication and Remote Control in PLC Based On ZigBee Technology
Li Pengfei
Li Jiakun
I.
Star ToPology
INTRODUCTION
Mesh ToPology
RFD
FFD
COORDINATOR
Tree ToPology
II.
Monitor PC
COORDINATOR
RFD
RFD
RS485
RS485
PLC
PLC
Elevator Model
Elevator Model
1
2
A. Hardware Design
This design of wireless digital module is based on the
Chipcon company CC2430 chip. The CC2430 comes in
three different versions: CC2430-F32/64/128, with
32/64/128 KB of flash memory respectively. The CC2430 is
a true System-on-Chip (SoC) solution specifically tailored
for IEEE 802.15.4 and ZigBee applications. It enables
ZigBee nodes to be built with very low total bill-of
material costs. The CC2430 is highly suited for systems
where ultra low power consumption is required. This is
ensured by various operating modes. Short transition times
between operating modes further ensure low power
consumption. The main characteristics of CC2430 chips are
listed:
High performance and low power 8051microcontroller
core;
2.4GHz IEEE 802.15.4 compliant RF transceiver
(industry leading CC2420 radio core);
Very few external components and Wide supply voltage
range (2.0V3.6V);
CSMA/CA hardware support and AES security
coprocessor[3].
CC2430 is a System-on-Chip, with abundant internal
system resources, so it only needs a little of peripheral
components to realize receive or send signals. Fig.3 shows a
typical application hardware circuit design of CC2430 chip,
which is adopted in the article. CC2430 can be used together
with various types of antennas. A differential antenna like a
dipole would be the easiest to interface not needing a balun
(balanced to un-balanced transformation network).
VCC~5V
CN3
AMS1117 J1
VIN
VOUT
C1
10uF
VCC~5V
A D J/G
III.
C2
104
1
2
3
4
5
6
7
8
9
10
11
12
1
2
3
4
5
6
7
8
9
10
11
12
12 HEADER
R11
1K
R4
470
GND
VDD
P0.7
P0.6
P0.5
P0.4
P0.3
P0.2
P0.1
P0.0
RST
P1.0
24
23
22
21
20
19
18
17
16
15
14
13
CN4
1
2
3
4
5
6
7
8
9
10
11
12
12 HEADER
J8
R9
10K
U2MAX485
2
C11
104
S1
SW-PB
GND
GND
DC/P2.2
DD/P2.1
P2.0
SO/P1.7
SI/P1.6
CLK/P1.5
CSN/P1.4
P1.3
P1.2
P1.1
DTD243A
D1
LED
U1
3
4
RO
VCC
RE
DE
DI
GND
VCC~5V
8
7
6
5
1
6
2
7
3
8
4
9
5
DB9
534
R5
470
Initialize
B. Soft Design
This design of wireless digital module adopt star
topology, program structure are also divided into two parts:
the program of COORDINATOR node and RFD node.
COORDINATOR node program mainly includes parameter
setting of communications between CC2430 and monitor PC,
forming a network and distributing each RFD a unique
network ID, and sending control signal to RFD; RFD node
program includes initialization, joining the network,
receiving function and mark code judging function etc. At
last, if RFD nodes judgement correct, it will transmit the
control signal to PLC. And the program flowchart of
COORDINATOR node and RFD nodes are listed as follow:
Successful
?
Y
Send joined signal and
wait for receiving data
Correct?
Y
Send control signal to PLC
Initialize
Receive PLC running
status signal and send it
to COORDINATOR
Exist wireless
signal?
Y
Distribute network ID
to RFD node
Send data to RFD
Wait for receiving
RFDs feedback
Send feedback to
monitor PC from
serial port
Figure 5. Flowchat of COORDINATOR
void receiveMode(void )
535
//receivng function
{
BYTE zz[] = "ctr1";
V.
REFERENCES
[1]
IV.
CONCLUSION
[2]
[3]
[4]
[5]
[6]
[7]
536
IEEE 802.15.4
Standard
Specification,downloadable
at
standards.ieee.org/getieee802/.
CC2430 Datasheet, Chipon Product from Texas Instryment.
Callaway,E.H,2004. Wireless Sensor Networks: Architectures and
Protocols.Auerbach Publication,USA,342pp.
Estin,D. Wireless sensor networks: application driver for low power
distribute systems.Low Power Electronics and Design,International
Symposium on 2001,194pp.
Chee-Yee
Chong,Kumar,S.P.
Sensor
networks:
evolution,opportunities and challenges.Proceedings of the
IEEE,2003,Vol,1347~1256pp.
Y. Yorozu, M. Hirano, K. Oka, and Y. Tagawa, Electron
spectroscopy studies on magneto-optical media and plastic substrate
interface, IEEE Transl. J. Magn. Japan, vol. 2, pp. 740741, August
1987 [Digests 9th Annual Conf. Magnetics Japan, p. 301, 1982].
Sajdl Ondej, Brada Zdenk, Fiedler Petr, Hynica Ondej, ZigBee
Technology and Device Design, Proceedings of the International
Conference on Networking, International Conference on Systems and
International Conference on Mobile Communications and Learning
Technologies, 2006 IEEE
L. Ruiz-Garcia, P. Barreiro J.I.Robla: Performance of ZigBee-Based
wireless sensor nodes for real-time monitoring of fruit logistics,
Journal of Food Engineering 87, 2008