8E- 164 ELECTRONIC CONTROL MODULES - ELECTRICAL DIAGNOSTICS —__________ PM
*NO RESPONSE FROM TCM (TRANSMISSION CONTROL MODULE) (CVT)
|imrecairee
joes
sbscl aad
For a complete wiring diagram Refer to Section 8W.PM ——__________ ELECTRONIC CONTROL MODULES - ELECTRICAL DIAGNOSTICS 8 - 165
Possible Causes
(A416) FUSED B(+) CIRCUIT OPEN OR SHORTED
(2967) GROUND CIRCUIT OPEN
(065) CAN C BUS (+) CIRCUIT OPEN
(064) CAN C BUS (-) CIRCUIT OPEN
TRANSMISSION CONTROL MODULE
Diagnostic Test
1. TEST FOR INTERMITTENT CONDITION
Turn the ignition on
NOTE: Ensure the IOD fuse is installed and battery voltage is between 10.0 and 16.0 volts.
With the scan tool, select ECU View.
NOTE: A red X will be next to the module that is not communicating, indicating that the module is not active
on the Bus network. A green check indicates that the module is active on the Bus network.
NOTE: Check the TIPM for any active CAN C hardware DTC's, perform DTC before proceeding.
Does the scan tool display a red X next to the module?
Yes >> GoTo2
No >> The no response condition is not present at this time. Using the wiring diagram/schematic as a guide,
inspect the wiring for chafed, pierced, pinched, and partially broken wires and the wiring hamess con-
nectors for broken, bent, pushed out, and corroded terminals.
2. (A416) FUSED B(+) CIRCUIT OPEN OR SHORTED
Tum the ignition off.
Disconnect the TCM C2 harness connector.
Using a 12-volt test light connected to ground, check the (A416) Fused
B(+) circuit
Does the test light illuminate brightly?
Yes >> GoTo3
No >> Repair the (A416) Fused B(+) circuit for an open or short.
Perform the CVT VERIFICATION TEST.
erred8E- 166 ELECTRONIC CONTROL MODULES - ELECTRICAL DIAGNOSTICS
3. (2967) GROUND CIRCUIT OPEN
Using @ 12-volt test light connected to 12-volts, check the (2967)
ground circuit
Does the test light illuminate brightly?
Yes >> GoTo4
No >> Repair the (Z967) ground circuit for an open,
Perform the CVT VERIFICATION TEST.
4. (065) CAN c BUS (+) CIRCUIT OPEN
artes
Tum the ignition off.
Disconnect the TIPM C3 hamess connector.
Disconnect the TCM C1 harness connector.
Measure the resistance of the (D65) CAN C Bus (+) circuit between the
TIPM C3 hamess connector and the TCM C1 hamess connector.
Is the resistance below 5.0 ohms?
Yes >> GoToS
No >> Repair the (D65) CAN C Bus (+) circuit for an open.
Perform the CVT VERIFICATION TEST.
~~
|
e17ecabePM ——_________ ELECTRONIC CONTROL MODULES - ELECTRICAL DIAGNOSTICS 8 - 167
5. (064) CAN ¢ BUS (-) CIRCUIT OPEN
Measure the resistance of the (D64) CAN C Bus (-) circuit between the
TIPM C3 hamess connector and the TCM C1 hamess connector.
Is the resistance below 5.0 ohms? OC)
Yes => Replace and program the Transmission Cont! Medlin . Co
Renee a progr te ara
Pestam fe anpopats VERIFICATION TEST pap
No >> Repair the (D64) CAN C Bus (-) circuit for an open. lpcogoccaal:
ren the Cv VERIFICATION TEST Pn oteneed
errs