Professional Documents
Culture Documents
LECT 01 Conventions of Drafting (Compatibility Mode)
LECT 01 Conventions of Drafting (Compatibility Mode)
Buildingconstruction
Semester1
LECTURE PREPARED BY FACULTY: DEEPIKA SHETTY
Draw the border and tittle block as follows for an A2 size sheet:
Note:
Border 1.5cm on top, bottom
and right sides
2.5 cm on the left side
Tittle block as shown in the fig.
DRAWING NO:1 A
DRAWING TITTLE: LINES- HORIZONTAL
DRAWING NO:1 B
DRAWING TITTLE: LINES- ANGULAR
DIVIDE THE SHEET INTO FOUR PARTS
DRAW VERTICAL (90
DEGREE) PARALLEL
LINES AT A SPACING
OF 0.5 MM.
DRAW 45 DEGREE
PARALLEL LINES AT A
SPACING OF 0.5 MM.
DRAW 30 DEGREE
PARALLEL LINES AT A
SPACING OF 0.5 MM.
DRAW 60 DEGREE
PARALLEL LINES AT A
SPACING OF 0.5 MM.
See That The Lines Are Of Uniform Thickness And Intensity As Discussed Before
Use A B Lead Pencil On White A2 Size Sheet With The Format And Tittle Block
As Shown Before.
DRAWING NO:1 C
DRAW 30 DEGREE
PARALLEL LINES AT A
SPACING OF 0.5 MM.
DRAW HORIZONTAL
PARALLEL LINES AT A
SPACING OF 0.5 MM.
References:
1. Prabhu Balagopal T.S.,Paul Vincent K., Vijayan C., Building design and
civil engineering drawing (1999), Spades Publishers and Distributers,
Calicut.
2. Shah M.G., Kale C. M., Patki S. Y., Building Drawing(2nd edition), Tata
McGraw-Hill Publishing Company, New Delhi.
3. IS 962, 1959, reaffirmed 2001, Code of Practice for Architecture and
Building Drawing second revision reprint 1993, Bureau of Indian
Standards, New Delhi.
4. SP46, 1988r, Engineering drawing practice for schools and colleges,
reprint 1988, Bureau of Indian Standards, New Delhi.
5. Ching Francis D.K., Architectural Graphics, 3rd edition, 1996, Van
Nostrand Reinhold, USA.