The document provides instructions for terminating cables by cutting the wire, stripping and arranging the wires in either a straight-through or crossover configuration, inserting the wires into an RJ-45 connector, and attaching the connector to the cable. It notes that a crossover cable follows the same steps but uses a different wire arrangement. The document also lists best practices for installing cables such as not bending or kinking the cable and using proper hangers rather than staples.
The document provides instructions for terminating cables by cutting the wire, stripping and arranging the wires in either a straight-through or crossover configuration, inserting the wires into an RJ-45 connector, and attaching the connector to the cable. It notes that a crossover cable follows the same steps but uses a different wire arrangement. The document also lists best practices for installing cables such as not bending or kinking the cable and using proper hangers rather than staples.
The document provides instructions for terminating cables by cutting the wire, stripping and arranging the wires in either a straight-through or crossover configuration, inserting the wires into an RJ-45 connector, and attaching the connector to the cable. It notes that a crossover cable follows the same steps but uses a different wire arrangement. The document also lists best practices for installing cables such as not bending or kinking the cable and using proper hangers rather than staples.
The document provides instructions for terminating cables by cutting the wire, stripping and arranging the wires in either a straight-through or crossover configuration, inserting the wires into an RJ-45 connector, and attaching the connector to the cable. It notes that a crossover cable follows the same steps but uses a different wire arrangement. The document also lists best practices for installing cables such as not bending or kinking the cable and using proper hangers rather than staples.
Step 2: Strip Wire and arrange as follows (Straight
Through Cable)
Step 3: Insert the wires into the RJ-45
Step 4: Permanently attach the RJ45 to the CAT5 cable.
Finished
Crossover cable
Follow the same steps to terminate a crossover
cable with one key difference Use the diagram on next slide for step 2
Crossover Cable
Remember
Maximum Cable length for including connectors is 100 meters
(or about 328 feet) Do not allow the cable to be sharply bent, or kinked, at any time. This can cause permanent damage to the cables' interior Do not over-tighten cable ties Do not use excessive force when pulling cable through floors, walls or ceilings Do not use staples to secure category-5 cable, use the proper hangers, which can be found at most hardware stores