Professional Documents
Culture Documents
Install and Uninstall Rms Software: 1. - System Requirements
Install and Uninstall Rms Software: 1. - System Requirements
501 DE SERVICE
RACK1 BS241 IIB
2. - PC is without RMS
If your PC has never installed RMS, please follow below to install this software.
3. - PC is with NRMS
Remove old versions
Follow the step of 2
4. - Uninstall
SYSTEM Components
In addition to PC whose operation system is Windows, the following components are
required:
NRMS Software-installed on the PC to control and monitor Telecom Power System.
RS-232 cable, TX and RX is parallel, for remote connection To connect Modem to
COM port on the PC.
Null Modem cable, TX and RX is crossover, for local connection To
connectCenter Supervisor Unit (CSU) to COM port on the PC.
Software function
5. - Permission Management
NRMS has four permission levels of system operation, setting and debug to suit each level
of user.
Function of each level:
1. USER level: Monitoring the parameter of system, Alarm and Even log.
2. ADMIN level: User level plus parameter setting and time setting.
CONFIGURACION CSU
501 DE SERVICE
RACK1 BS241 IIB
2.- Luego que este conectado (en parte izquierda inferior de pantalla en ON)
dirigirse a SETTING-CHANGE PERMISSION colocar en Permission ID ADMIN
y password 0000 ENTER
CONFIGURACION CSU
501 DE SERVICE
RACK1 BS241 IIB
CONFIGURACION CSU
501 DE SERVICE
RACK1 BS241 IIB
CONFIGURACION CSU
501 DE SERVICE
RACK1 BS241 IIB
CONFIGURACION CSU
501 DE SERVICE
RACK1 BS241 IIB
CONFIGURACION CSU
501 DE SERVICE
RACK1 BS241 IIB