Professional Documents
Culture Documents
HC-05 Datasheet 201104 Revised
HC-05 Datasheet 201104 Revised
Rev 1
10
1.01
2010/5/15
2011/4/6
MODEL :
DRAWN BY :
HC-05
Ling Xin
Description:
CHECKED BY :
Eric Huang
APPD.
BY
Former version
Simon Mok
REV :
2.0
PAGES:
introduction
www.wavesen.com Phone: 020-84083341 Fax: 020-84332079 QQ:1043073574
Address: Room 527, No.13, Jiangong Road, Tianhe software park, Tianhe district, Guangzhou
Post: 510660
Business consultant:sales@wavesen.com
Technology consultant: support@wavesen.com
Complaint and suggestion: sunbirdit@hotmail.com
Contents
1. Products picture
2. Feature
3. Pins description
4. The parameters and mode of product
5. Block diagram
6. Debugging device
7. Characteristic of test
8. Test diagram
9. AT command set
1.Products picture
2. Feature
Wireless transceiver
-4 - +6dBm.
Low Cost
Application fields:
Bluetooth Car Handsfree Device
Bluetooth GPS
Bluetooth PCMCIA , USB Dongle
3PINs description
PIN Name
GND
1V8
14
VSS
VDD
Ground pot
Integrated 1.8V (+)
supply with On-chip linear
regulator output within
1.7-1.9V
VCC
12
3.3V
AIO0
Bi-Directional
AIO1
10
Bi-Directional
PIO0
PIO1
PIO2
23
24
25
Bi-Directional
RX EN
Bi-Directional
TX EN
Bi-Directional
Programmable
input/output line
Programmable
input/output line
Programmable
input/output line, control
output for LNA(if fitted)
Programmable
input/output line, control
output for PA(if fitted)
Programmable
Note
input/output line
Programmable
PIO3
26
Bi-Directional
PIO4
27
Bi-Directional
PIO5
28
Bi-Directional
PIO6
29
Bi-Directional
PIO7
30
Bi-Directional
PIO8
31
Bi-Directional
PIO9
32
Bi-Directional
PIO10
33
Bi-Directional
PIO11
34
Bi-Directional
RESETB
11
UART_RTS
UART_CTS
internal pull-down
low
UART_RX
UART_TX
SPI_MOSI
17
SPI_CSB
16
SPI_CLK
19
input/output line
Programmable
input/output line
Programmable
input/output line
Programmable
input/output line
Programmable
input/output line
Programmable
input/output line
Programmable
input/output line
Programmable
input/output line
Programmable
input/output line
internal pull-up
CLK_REQ
CLK_OUT
internal pull-down
clock
Serial peripheral interface
data Output
SPI_MISO
18
USB_-
15
Bi-Directional
USB_+
20
Bi-Directional
Default :
1.8V external power
1.8V
14
PCM_CLK
Bi-Directional
PCM_OUT
CMOS output
PCM_IN
CMOS Input
PCM_SYNC
Bi-Directional
supply input
1.8V
internal power
supply.
5. Block diagram
6. Debugging device
6.1 Device
PC, hardware, 3G3G Frequency Counter (SP3386), 3.15V DC power supply, ShieldingBluetooth
Test box.
6.2 Software
7. Characteristic of test
Test Condition 25 RH 65%
Min
2.4
Max
Unit
2.4835
MHz
4
8
dBm
dB
1.
Carrier Freq.
2.
3.
RF O/P Power
Step size of Power control
-6
2
4.
-75
75
KHz
5.
-20
20
KHz
1 slot packet
3 slot packet
-25
-40
25
-40
KHz
KHz
175
KHz
6.
( ISM Band )
Typ
Freq. Deviation
Ratio of Freq. Deviation
7 . Receive Sensitivity @< 0.1% BER( Bit error rate )
115
KHz
0.8
-83
dBm
8. Test diagram
3GHz Ferq.
Counter
RS232
CH C
RF
COM 1
O/P
LPT1
UUT
Interface
circuit
Computer
SPI
Shielding Box
GPIB
Bluetooth test
set
RF I/P
Computer
COM 1
LP1
RS232
RF Port
UUT
SPI
Shielding Box