Professional Documents
Culture Documents
Thermo Fluids 2014 Assignment 2
Thermo Fluids 2014 Assignment 2
(6) Last date of submission 14th June 2015. Strictly no late submissions will be accepted
due to any reason. .
1)
a) A uniform film of oil 0.13 mm thick separates two discs, each of 200 mm diameter
mounted co axially. Ignoring edge effects, calculate the torque necessary to rotate
one disc relative to the other at a speed of 7rev/s if the oil has a viscosity of 0.14 Pas.
Figure Q1 (b)
2) A 45 reducing bend is connected in a pipe line the diameter at the inlet and outlet of the
bend being 600 mm and 300 mm respectively. Find the force exerted by water on the
bend if the intensity of pressure at the inlet to bend is 8.829 N/cm 2 and rate flow of
water is 600 liters / sec.
0
3) A sheet piling holds fresh water and salt water (relative density = 1.035) on either sides
of it as shown in Figure Q3. Find the moment about the base M of the resultant force per
unit length of filing?
Figure Q3
5) A venture section of a pipe develops a low pressure which can be used to aspirate fluid
upward from reservoir as shown in Figure Q5. Show the exit velocity V 2 is just
sufficient to cause the reservoir fluid to rise in the tube up section 1 if
2 gh
V 2
D2 4
1
D1
( )
Figure Q5
6) Calculate the flow through each of the pipes of the network shown in Figure Q6.
Figure Q6
3