Professional Documents
Culture Documents
Reference Photo:: 6 In. (152.4mm) ATJ-4
Reference Photo:: 6 In. (152.4mm) ATJ-4
(152.4 mm)
tooth shape, intermesh, and cone offset. The projection and shape of the
teeth combine to form an effective cutting structure for hard streaks as
well as milling purposes.
for broad WOB needs. Bit is normally used for clean out runs, drilling
"junk", and / or drilling non-PDC drillable float equipment.
Product Specifications
IADC:
216
Bearing / Seal Package:
Journal / O-ring
Cutting Structure:
Inner Row
Self-sharpening
Heel Row
Self-sharpening
Gauge Row
Standard
Gauge Trimmers
N/A
Tooth Hardfacing:
Standard
OD Hardfacing:
Shirttail
Nozzle Type:
Standard
Center Jet Display:
N/A
Makeup Torque:
7.0 - 9.0 klbf-ft (9.5 - 12.2 kNm)
Connection:
3-1/2 REG API
Approx. Shipping Weight:
38 lb ( 17.2 kg)
A60J457
Reference Part Number:
Operating Recommendations*:
Weight On Bit:
Rotation Speed:
*The ranges of bit weight and RPM shown are representative of typical operating
parameters, but will not necessarily yield optimum bit life or lowest drilling cost. It is
not recommended that the upper limits of both weight and RPM be run simultaneously.
Contact your local Hughes Christensen representative for recommendations in your area.
bhiTrackPage("Bit","Bit Stylesheet"); %>
www.bakerhughes.com