# LibMaterialsRC.tcl: define a library of Reinforced-Concrete materials
# Silvia Mazzoni & Frank McKenna, 2006 ########################################################## # General Material parameters set G $Ubig; # make stiff shear modulus set J 1.0; # torsional section stiffness (G makes GJ large) set GJ [expr $G*$J]; # ----------------------------------------------------------------------------------------------------# confined and unconfined CONCRETE # nominal concrete compressive strength set fc [expr -4.0*$ksi]; # CONCRETE Compressive Strength, ksi (+Tension, -Compression) set Ec [expr 57*$ksi*sqrt(-$fc/$psi)]; # Concrete Elastic Modulus set nu 0.2; set Gc [expr $Ec/2./[expr 1+$nu]]; # Torsional stiffness Modulus # confined concrete set Kfc 1.3; gth set Kres 0.2; set fc1C [expr $Kfc*$fc]; mum stress set eps1C [expr 2.*$fc1C/$Ec]; set fc2C [expr $Kres*$fc1C]; set eps2C [expr 20*$eps1C]; set lambda 0.1; tial slope $Ec # unconfined concrete set fc1U $fc; l), maximum stress set eps1U -0.003; ed concrete set fc2U [expr $Kres*$fc1U]; set eps2U -0.01; # tensile-strength properties set ftC [expr -0.14*$fc1C]; set ftU [expr -0.14*$fc1U]; set Ets [expr $ftU/0.002];
# ratio of confined to unconfined concrete stren
# ratio of residual/ultimate to maximum stress # CONFINED concrete (mander model), maxi # strain at maximum stress # ultimate stress # strain at ultimate stress # ratio between unloading slope at $eps2 and ini # UNCONFINED concrete (todeschini parabolic mode # strain at maximum strength of unconfin # ultimate stress # strain at ultimate stress # tensile strength +tension # tensile strength +tension # tension softening stiffness
# set up library of materials
if { [info exists imat ] != 1} {set imat 0}; # set value only if it h as not been defined previously. set IDconcCore 1 set IDconcCover 2 uniaxialMaterial Concrete02 $IDconcCore $fc1C $eps1C $fc2C $eps2C $lambda $ftC $ Ets; # Core concrete (confined) uniaxialMaterial Concrete02 $IDconcCover $fc1U $eps1U $fc2U $eps2U $lambda $ftU $Ets; # Cover concrete (unconfined) # ----------------------------------------------------------------------------------------------------# REINFORCING STEEL parameters # set Fy [expr 66.8*$ksi]; # STEEL yield stress set Es [expr 29000.*$ksi]; # modulus of steel set Bs 0.01; # strain-hardening ratio set R0 18; # control the transition from elastic to plastic
branches set cR1 0.925; branches set cR2 0.15; branches