ena sto 2931-50A10
reel PROCESS | PIPING MATERIAL SPECIFICATION soe BG
WHEELER i PLANTS
revision 1
LIMITED DIVISION
PATE October
Sheet any October 1979
Carros
RL Steam Tracing (See Note 2, & 3) a wai
Service gate —
Inspection Class See Note 4
fating ‘Stress
None Relief None
Press/terp. Rating None Big Packing
5 Test
a ‘Temp, Limits 204°C Max. (See Note 2 & 3) paeeoet See Note 5 |
Material
Carbon Steel Piping and
f Copper Tubing
Inch Si:
ten tae ae Description ‘Specification
TUBING x & 0.035" Wall. Seamless Copper Tubing to ASTM B68, annealed.
7 [Gee 0.0.| 0.D.| To be purchased in longest possible coiled lengths.
Wote 6)
‘TUBE Brass 3-piece flareless type compression fitting, consisting
FITTINGS of body, nut and ferrule.
steam | 4 Forged carbon steel body with top entry stainless steel
mr | Ne. Fenevable internels. Binetallic type. Integral strainer.
(TO BE Non-return valve action. End connections socket weld.
PERMAN- Requisition to state steam supply conditions and whether
ENTLY trap discharges to open or closed condensate system.
TAGGED
Tl)
Carbon Steel piping shall be used for Steam and Condensate leads and manifolds.
(See Note 3). .
1. Design and installation of steam tracing shall be in accordance with F.W.L.
Eng. Std. 56A1.
2. This Class is intended for use with Steam or Process lines with a 400°F
(204°C) Max. operating temperature.
RL |3, Piping Class is dependant on steam pressure/temperature (Saturated).
4. For Weld Quality Insp. Class on carbon steel piping refer to Piping Class
used for Tracing Steam.
Piping shall be Service Tested to maximum working pressure.
6." end $"0.D. tubing shall only be used where necessary around valves,
instruments and other irregular shaped objects.