Professional Documents
Culture Documents
Binary Amplitude Shift Keying With PWM Input
Binary Amplitude Shift Keying With PWM Input
R2
8k2
A
B
C
GENERATOR 3
DC
C2
5
AM
CV
10n
FM
TR
TH
GND
OA91
VCC
GENERATOR 1
U1
D?
AM
FM
NE555
C1
10n
U2:A
GENERATOR 2
4016
1
13
AM
FM
U2:C
4016
X
U3:A
2
1
74LS04
Procedures
1. The circuit is connected as per the circuit diagram shown in fig 1.
2. Adjust signal generator 1 to give the pulse of 6KHz with 5Vp-p, Set a signal
generator 3 to give 0Hz with 0Vp-p and adjust signal generator 2 to give
100KHz with 5Vp-p. Discuss your observation at ASK output.
3. Increase the frequency of signal generator 3 to 6KHz with amplitude of
5Vp-p. Leaving all other settings as in task2, discuss your observation at ASK
output.
4. Change frequency of signal generator 3 to 7KHz. Keeping other settings
constant, discuss your observation at ASK output.
5. Observe on the BASK modulation signal by changing the frequency of
generator to 8kHz, 9kHz, 10kHz, 6KHz, 7KHz. (All other parameters are kept
constant at as in task 2 above)