Professional Documents
Culture Documents
Demo Instructions - Comando Agujero
Demo Instructions - Comando Agujero
Demo Instructions - Comando Agujero
Demo Steps
Page 1 of 5
AUTODESK CONFIDENTIAL
Page 2 of 5
AUTODESK CONFIDENTIAL
Use the Linear placement option (default) to place two holes on the machined face of the
rectangular boss to match the existing holes
o The holes should be m6x1 tapped holes with a 6mm countersink and a depth of 10mm
o Use the Apply button between each feature to demonstrate the streamlined workflow
Use the Concentric placement option to place three holes of the same size on the three small,
machined flanges
o Note to users that holes may be placed concentric to a circular edge or a cylindrical face
-demonstrate both methods
o Use the Apply button between each feature
Page 3 of 5
AUTODESK CONFIDENTIAL
Use the On Point placement option again to place two Clearance holes on Work Points 1 &
2 (located on the large flanges). Select he faces on which the points lie to define the hole
direction.
o Specify Loose fit clearance holes with counterbores for 6mm Ansi Metric Hex Head
Cap Screws
o Use the Apply button between each feature
o Note to users that the data for Clearance holes is stored in the Clearance.xls
spreadsheet in the Design Data folder
Page 4 of 5
AUTODESK CONFIDENTIAL
Figure 7
End of Demo
Page 5 of 5
AUTODESK CONFIDENTIAL