The document describes configuring security and network settings on a switch named S1. It assigns the hostname S1, sets the console password to "letmein" and privileged mode password to "c1$c0". It also configures S1 with the IP address 192.168.1.253, subnet mask 255.255.255.0 on interface VLAN 1.
The document describes configuring security and network settings on a switch named S1. It assigns the hostname S1, sets the console password to "letmein" and privileged mode password to "c1$c0". It also configures S1 with the IP address 192.168.1.253, subnet mask 255.255.255.0 on interface VLAN 1.
The document describes configuring security and network settings on a switch named S1. It assigns the hostname S1, sets the console password to "letmein" and privileged mode password to "c1$c0". It also configures S1 with the IP address 192.168.1.253, subnet mask 255.255.255.0 on interface VLAN 1.
To secure access to the console line, access config-line mode and set the console password to letmein. S1# configure terminal Enter configuration commands, one per line. End with CNTL/Z. S1(config)# line console 0 S1(config-line)# password letmein S1(config-line)# login S1(config-line)# exit S1(config)# exit %SYS-5-CONFIG_I: Configured from console by console S1#
Secure privileged mode access
S1> enable S1# configure terminal S1(config)# enable password c1$c0 S1(config)# exit %SYS-5-CONFIG_I: Configured from console by console S1#
Use the following commands to configure S1 with an IP address.
S1 #configure terminal Enter configuration commands, one per line. End with CNTL/Z. S1(config)# interface vlan 1 S1(config-if)# ip address 192.168.1.253 255.255.255.0 S1(config-if)# no shutdown %LINEPROTO-5-UPDOWN: Line protocol on Interface Vlan1, changed state to up S1(config-if)# S1(config-if)# exit S1# copy run start