Remove the spare tire jack and handle assembly. Remove the carpet pin-type retainers and pull the carpet back. Position the rear window glass to the 3 / 4 down position.
Remove the spare tire jack and handle assembly. Remove the carpet pin-type retainers and pull the carpet back. Position the rear window glass to the 3 / 4 down position.
Remove the spare tire jack and handle assembly. Remove the carpet pin-type retainers and pull the carpet back. Position the rear window glass to the 3 / 4 down position.
Rear Window Glass Regulator Removal and Installation 1.
Fold down the rear seat backs.
2.
Fold the loadspace trim panels up and remove
the luggage compartment lower screws and loadspace trim panel.
3.
4.
5.
Remove the spare tire jack and handle
assembly.
6.
If equipped, remove the sub-woofer assembly.
Remove the pin-type retainers from the luggage
compartment trim panel.
Disconnect the electrical connector.
Remove the bolts.
Open the luggage compartment trim panel
access doors and remove the four pin-type retainers and the luggage compartment trim panel.
Copyright 2004, Ford Motor Company
Last updated: 06/23/2004
2005 Explorer Sport Trac, 9/2004
501-11-2
Glass, Frames and Mechanisms
501-11-2
REMOVAL AND INSTALLATION (Continued)
7.
Remove the carpet pin-type retainers and pull
the carpet back.
10. Position the rear window glass to the 3/4 down
position. For additional information, refer to Rear Window Positioning in this section. 8.
NOTE: The rear window glass water shield
uses a reusable butyl rubber adhesive. A new water shield does not have to be installed unless it is damaged or if the butyl rubber adhesive does not adhere to a section of the sheet metal. Remove the water shield from the rear window glass motor.
11. Disconnect the rear window glass regulator
motor electrical connector. 12. Remove the rear window glass bolts.
9.
Position the rear window glass regulator access
panel aside. 1
Remove the screws.
Remove the nut.
Position the rear window glass regulator
access panel aside.
13. Secure the rear window glass in the full closed
position.
2005 Explorer Sport Trac, 9/2004
501-11-3
Glass, Frames and Mechanisms
501-11-3
REMOVAL AND INSTALLATION (Continued)
14. Remove the upper rear window glass regulator bolts.
16. Remove the rear window glass regulator
assembly.
15. Loosen the right and lower rear window glass
regulator drum housing bolts, and remove the left rear window glass regulator drum housing bolt.
Position the slider to the midway point.
17. If necessary, transfer the rear window glass
motor. 18. NOTE: The rear window glass motor must be initialized after a repair has been carried out. For additional information, refer to Rear Window Motor Initialization in this section. To install, reverse the removal procedure.