Professional Documents
Culture Documents
EN10346-2009-7.5.2 Types of Surface Qualities
EN10346-2009-7.5.2 Types of Surface Qualities
EN 10346:2009 (E)
7.5.2
7.5.2.1
Imperfections such as pimples, marks, scratches, pits, variations in surface appearance, dark spots, stripe
marks and light passivation stains are permissible. Stretch levelling breaks or run-off marks may appear. Coil
breaks and stretcher strains may appear as well.
7.5.2.2
Surface quality B is obtained by skin passing. With this surface quality, small imperfections such as stretch
levelling breaks, skin pass marks, slight scratches, surface structure, run-off marks and light passivation stains
are permissible.
NOTE
For special applications and by agreement at the time of enquiry and order, hot-dip aluminium-silicon coated
products (AS) may be supplied with a bright appearance. In that case the surface is of type "B".
7.5.2.3
Surface quality C is obtained by skin passing. The controlled surface shall make it possible to apply a uniform
high-class paint finish. The other surface shall at least have the characteristics of surface quality B (see
7.5.2.2).
7.5.3
Roughness
A range for surface roughness (Ra values) and their verification may be agreed at the time of enquiry and
order. This does not apply for the non-skin passed condition (surface quality A).
7.6
7.6.1
General
At the time of enquiry and order one of the following surface treatment conditions shall be agreed:
chemically passivated
oiled
CO
phosphate
PO
sealed
NOTE 1
The effect of the surface protection "oiled especially depends on the temporary impact by storage and
transport. (see 6.2.3).
The products are only supplied without surface treatment (untreated (U)) if expressively desired by the
purchaser on his own responsibility (see also NOTE 2 at the end of this sub-clause).
Usually the products are supplied chemically passivated and/or oiled. In the case of oiling, both sides are
corrosion protected by a layer of neutral non-drying oil, free of impurities and uniformly spread. Under normal
packing, transportation, loading and storage conditions, there will be no corrosion for up to three months
starting from the date when the product is available at the manufacturer's work. However the period of
protection afforded depends on the atmospheric and storage conditions.
25