Professional Documents
Culture Documents
NEC Link Cong - Step
NEC Link Cong - Step
NE Login
1. Connect the PC to the LCT port of IDU.
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
Equipment Configuration
1. Expand Equipment Setup -> Equipment Configuration from the WebLCT
menu.
2. Click the Setup.
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
5. Confirm that the setup parameter changes to blue, and then click OK
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
Radio Configuration
1. Expand Equipment Setup -> Radio Configuration from the WebLCT menu.
2. Click Setup. The Step1 Window appears
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
5.
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
4.
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
10
TX Power Setting
1. Expand Provisioning -> MODEM Function Setting-> TX Power Setting
2. Click the MODEM1 to configure. The TX Power Setting dialog box appears.
Then, click OK
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
11
4. The default IP address is 172.18.0.1 for Near End site IDU, 172.18.0.2 for Far End
site IDU.
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
12
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
13
2. Click the Modify button. The E1 Port Setting (Main Board) dialog box appears
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
14
Click the Add button. Then configure the Cross connect between E1 interface and
Modem.
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
15
2.
Click the desired Port No. to configure. The ETH Port Setting dialog box appear
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
16
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
17
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
18
Notes1.Select which Port will be used, and the Vlan mode is Access or
Trunk depend on the BTS. If the IP packet from BTS with TAG, select
Trunk mode. If no Tag, select Access mode.
2. Setting Modem1 as Trunk mode, too(must be Trunk mode).
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
19
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
20
2. Click MODEM1
3. Confirm the RX level is up to the design value, and the BER is better than 0.0E-6
4. Expand Current Status-> Active alarm
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
21
2. Click Modem1
<>
All Rights reserved, No Spreading abroad without Permission of ZTE
22