Professional Documents
Culture Documents
Wrong Way Right Way: 6' To 8' 6' To 8'
Wrong Way Right Way: 6' To 8' 6' To 8'
8'
6' to
8'
WRONG WAY
RIGHT WAY
RIGHT WAY
Tarp
6'
Air Circulation
Mi
n.
10
'M
in.
15
L Trim
ab
le
to
Roof Panels
ab
1''
Insulation
Purlins
2'
le
2'
L Trim
(both sides of roof)
L Trim
Lay roofing panel on edge of roof even with edge of gable trim.
Install 1'' screws in every lower channel and into each purlin location moving toward the top of the roof. See screw fastening recommendations below. Make sure bottom edge is 1'' on both sides. Measure each panel to ensure a 1'' overhang.
1''
Correct
Lap
Detail
16
Place gable trim on gables. Cut to the proper length of the gable roof edges. Use 1'' screws every 12'' apart
while keeping the trim flat and straight. Screw into gable trim board. Place on each edge highlighted in red.
Gable
Trim
Profile
17
Lay ridge-cap on roof. Start flush or with slight overhang at gable. Mark edge of ridge-cap with pencil.
Remove ridge-cap and place self-adhesive closure gasket across roof panels just above the marks.
Remove ridge-cap and place self-adhesive closure gasket across roof panels just above the marks.
Ridge
Place relay ridge-cap down to cover gasket. Secure on every
roofing ridge on both sides of the ridge cap with 2'' screws.
Continue pattern across roof. Overlap joints to next ridge.
18