Professional Documents
Culture Documents
Final Manual Front
Final Manual Front
Parts
FRONT
Welcome
BACK
Syringe
grip
Flange
support
Rod end
Motor
2.5 mm
Allen key
included
Case
Extrude
Experiment
Explore
Motor
wires
Base
Cartridge Assembly
LUER LOCK
CONNECT
Step 2
Connect cartridge according to
schematic on right.
Syringe
Step 3
Load syringe on to Discov3ry
using two points of contact:
(1) syringe grip
(2) rod end
Female
connect
Step 4
Insert flange support.
Step 5
Connect tip to 3D printer.
Connect
At the back of the unit you will find four coloured wires
which must be matched to your 3D printer board motor
leads. The Discov3ry a color code that may differ from your
individual printer. Alternatives included below.
SLIC3R
SKEINFORGE
SIMPLIFY 3D
REPETIER
PRONTERFACE
G-codes
M302 - Allow cold paste extrusion
M92 E(xyz) - Set extruder steps/mm (where xyz is steps/mm)
M500 - Store new temporary M92 settings
M501 - Set temporary parameters to current M92 settings
M502 - Restore printer default M92 settings
M503 - Display current M92 settings
For more information visit www.structur3d.io/help
Syringe Tips
Step 1
Load syringe with paste.
Software
Custom Work
POLYPROPYLENE TIPS
Discov3ry
Code 1
Code 2
Bipolar
Code 3 Driver
Black
Green
Yellow
Red w/
White 4 or B
Green
Red
Red
Green 3 or B
Blue
Blue
Orange
Red w/
White 2 or A
Red
Yellow
Brown
Red
1 or A
Tips on Maintenance
Ensure wires are in good working order
before use.
Ensure fasteners and nuts are tightened
properly (2.5 mm Allen key, 3/8 bit).
Female
Blue
Red
Green
Olive
0.25mm 0.41mm 0.84mm 1.54mm
internal diameter
STAINLESS-STEEL TIPS
(6.35mm length)
Male
Male
connect
Tip
COVER
Red
0.25mm
Pink
0.61mm
internal diameter
Amber
1.36mm