Professional Documents
Culture Documents
Method Statement For Painting of Valves
Method Statement For Painting of Valves
VALVES
A
Rev.
Description
31-08-14
Date
FA
Prepared
MB
Checked
TABLE OF CONTENTS
AR
MA
ILG
QA
review
Safety
review
Approved by
1.0
PURPOSE2
2.0
WORK
3.0
4.0
PROCEDURE2
PURPOSE
After receiving the valves from the Client then the painting works will be carried out. In this
Method statement will show the procedure on how painting activities will be done.
The purpose of this method is to describe the measures and ways of proper application of
paint applicable. Works should be carried out in compliance with the drawings, project
specifications and materials.
WORK PROCEDURE
Valves which shall be covered / protected appropriately before surface preparation and
painting will commence. Clean and prepare surface is to be painted. Efflorescence, chalk,
dust, dirt, grease and oil shall be removed.
The paint system would be approved by the client engineer. The intermediate paint and the
final paint must be compatible with the primer. Both the intermediate and final paint applied
are from the same manufacturer as that of the primer. The paint would be applied by airless
machine. Primer has already been applied on the valves.
Firstly two coats would be applied on the valves. But each coat shall have an interval time of
4 hours of curing. Before the application of second coat cleaning and removing off
splattered, blemishes and stains on the painted surface shall be done.
Then two coats of final paint would be applied as per the approved RAL color.
Inspection request to be submitted for checking and approval of Client Engineer.
Safety Measures
1.
2.
3.
4.
All works shall comply with safety procedure or instruction set out in project safety.
Basic PPE to be worn by all staff or laborers.
All Operatives involve in this work shall be inducted before entering the site.
Tool box talk shall be conducted regularly.
4. Pail
5. Sand paper
6. Rug cloth