Professional Documents
Culture Documents
Multimodalinstructions
Multimodalinstructions
a. Assure all
stripped wire
(wire that is
divided into
three separate
wires) is in the
box.
5 cont.
a. Assure
stripped
wire is
inside
each box.
5 cont.
5 cont.
5 cont.
5 cont.
5 cont.
7 cont.
a. This keeps
the wires
from pulling
out of the
boxes.
7 cont.
a. To do this,
hold the wires
side by side.
8 cont.
8 cont.
b. Then,
twist the
nut
clockwise
until the
wires
begin to
twist
around
one
another.
c.
Tighten
until nut
is firmly
secure.
9 cont.
a. Keep the
wires side by
side.
b. Slide the
green wire nut
over the longer
wire, allowing it
to pass through
the top of the
nut.
9 cont.
10
c. Tighten the
nut the same
as you did in
Step 8c.
10 cont.
10 cont.
a. The J
should be
tight
enough to
stay around
the screw.
b. Using the
needle nose
pliers, pinch
the bare end
of each wire
and bend it to
ake the J
shape.
11
11 cont.
a. Two black
wires at the
switch box
x3
b. Two bare
wires at the
light box
c. One white
wire at the light
box
12
13
13 cont.
14
15
16
Locate the light switch. There are ovalshaped holes on the top and bottom of the
17 switch.
18
20
a. Locate the
two screws
passing
through
these holes.
These screws
are mounting
screws and
will secure
the switch to
the box.
19
20 cont.
20 cont.
a. J-hook
the white
wire to the
white
screw
. J-hook
the black wire
to the gold
screw
20 cont.
. J-hook
the bare wire
to the green
screw
a. Tuck them
in so that the
mounting
screws align
into the
screw holes
on the box.
23
a. Allow the
mounting
screws to
pass through
the keyshaped
screw holes
on the light
base.
a. Make
sure that
screw holes
on the panel
and box line
up.
25 cont.
26
a. To
install,
turn the
lightbulb
clockwise
until it is
secure.
*Flip the
switch up
to turn on
the light.
*Flip it
down to
turn off
the light.