Professional Documents
Culture Documents
Common Layout Tools - Smithy
Common Layout Tools - Smithy
Common Layout Tools - Smithy
CommonLayoutTools|smithy.com
18004764849
ShoppingCart ContactUs
Search
AboutUs
MachineTools
Accessories
Support
EmailDeals
MachiningHelp
CommonLayoutTools
Scriber
Toobtainanaccuratelayout,finelinesmustbescribedin
themetal.Ascriber(Figure13)isthelayouttoolthatisused
toproducetheselines.Thepointismadeofhardenedsteel
andiskeptchainbyhoningonanoilstone.
FinancingOptions
CONSUMER/PERSONAL:
CreditPlan:
5.99%APR
with48MonthlyPayments*
*Thereisapromotionalfeeof
$125forthistransaction.
Offersubjecttocreditapproval.
Figure15.Usingdividertolayoutequalmaesurement.
Figure13.Scribers.
COMMERCIAL/BUSINESS:
Leasing&FinancingOptionsToFit
YourNeeds
Divider
Whenlayingoutcircles,arcs,andradii,itisbesttousethe
divider (Figure 14). The legs of the divider must be of the
samelengthandbekeptsharp.Thedividercartbeusedto
lay out and measure distances (Figure 15). To set the
dividertothecorrectlength,placeonepointonaninchmark
of a steel rule and open the divider until the other leg
matchesthecorrectmeasuremeritrequired(Figure16).
90DayHandsOnTrial
GuaranteeTrya3in1
machinefor90days!
Navigation
MachiningHandbookadaptedfromtheUS
Army'sHandbook"FundamentalsofMachine
Tools"
Figure16.Correctmethodsofsettingdivider
Chapter1.IntroductiontotheMachineShop
IntroductiontotheMachineShop
MachineShopWork
CommonLayoutTools
GeneralShopSafety
SafetyColorCodeAndSigns
Chapter2.Properties,Identificationand
HeatTreatmentofMetals
Chapter3.Lathes
Chapter4.MillingOperations
Chapter5.Milling,Grinding,DrillingAnd
SlottingAttachments
Chapter6.DrillingMachines
Chapter7.SawingMachines
Chapter8.GrindingMachines
Chapter9.PortableMachineTools
Figure14.Divider
Trammel
Whenscribingcircles,arcs,andradiithataretoolargeto
be produced with the divider, a trammel should be used
(Figure17). The trammel is made of three main parts: the
beam,twoslidingheadswithscriberpoints,andanadjusting
screwthatisattachedtooneoftheheads.Thetrammelcan
bemadetoscribelargerdistanceswiththeuseofextension
rods. This layout tool is set in the same manner as the
divider.
Figure17.Trammel.
Figure110.Obtainingcenterofacylindricalwork.
SurfaceGage
HermaphroditeCalliper
Thehermaphroditecalliper(Figure18)isatoolusedto
layout lines that are parallel with the edges of the work
piece(Figure19).Itcanalsobeusedtolocatethecenterof
cylindricalshapedworkplaces(Figure110).
http://www.smithy.com/machininghandbook/chapter1/page/3
1/5