Professional Documents
Culture Documents
WhisperTek Dual Installation Guide
WhisperTek Dual Installation Guide
TABLE OF CONTENTS
Before you begin
14
Measuring tape
Laser level
3" roller
WhisperTek
Surface installation
http://nureva-span.uservoice.com/knowledgebase/articles/603927
70F
21C
Pa g e 3
STEP 1
Pa g e 4
Set up the laser lever and project a line 1" above the projected image.
Find the overall centerline of the system. Each surface is 124" (314 cm) long and should extend 1" past the projected
image. Once you have found the centerline, use a straight edge to mark the entire length of the centerline.
Pa g e 5
STEP 2
A L I G N I N G S U R FA C E 1
Pa g e 6
Pa g e 7
Align surface 1
Do not let the exposed adhesive touch the wall during this step.
Pa g e 8
STEP 3
A D H E R I N G S U R FA C E 1
Pa g e 9
Pa g e 1 0
Pa g e 1 1
Pa g e 1 2
CBA
Pa g e 1 3
STEP 4
M O U N T I N G S U R FA C E 2
Pa g e 1 4
N u reva W h i s p e rT e k d u a l i n sta l l at i o n g u i d e F e b r u a r y 2 0 1 6
Pa g e 1 5
N u reva W h i s p e rT e k d u a l i n sta l l at i o n g u i d e F e b r u a r y 2 0 1 6
Pa g e 1 3
Person B walks the edge of the surface away from the wall so person A can get behind the surface to remove the liner
from where it was folded.
While person B holds the outside edge, person A goes back to the front of the surface and smoothes that half of the
surface against the wall starting at the centerline using overlapping up-and-down strokes.
Once person A adheres that side of the surface, person A then goes behind the surface again to remove the second
half of the liner to smooth that side of the surface against the wall.
Pa g e 1 7
2016 Nureva Inc. All rights reserved. Nureva, Span, WhisperTek and the Span logo are trademarks of Nureva Inc. in the United States, Canada and other countries.
Nureva WhisperTek dual installation guide February 2016
Pa g e 1 8