Professional Documents
Culture Documents
NSUR2-1 Whispertek™ Surface Dual Installaton Guide: ™ Ideation System
NSUR2-1 Whispertek™ Surface Dual Installaton Guide: ™ Ideation System
TABLE OF CONTENTS
Before you begin
14
Measuring tape
Laser level
3" roller
WhisperTek
Surface installation
http://nureva-span.uservoice.com/knowledgebase/articles/603927
70F
21C
STEP 1
Set up the laser lever and project a line 1" above the projected image.
Find the overall centerline of the system. Each surface is 124" (314 cm) long and should extend 1" past the projected
image. Once you have found the centerline, use a straight edge to mark the entire length of the centerline.
STEP 2
A L I G N I N G S U R FA C E 1
Align surface 1
Do not let the exposed adhesive touch the wall during this step.
STEP 3
A D H E R I N G S U R FA C E 1
10
11
12
CBA
13
STEP 4
M O U N T I N G S U R FA C E 2
14
15
16
Person B walks the edge of the surface away from the wall so person A can get behind the surface to remove the liner
from where it was folded.
While person B holds the outside edge, person A goes back to the front of the surface and smoothes that half of the
surface against the wall starting at the centerline using overlapping up-and-down strokes.
Once person A adheres that side of the surface, person A then goes behind the surface again to remove the second
half of the liner to smooth that side of the surface against the wall.
Nureva WhisperTek dual installation guide February 2016
17
Nureva
WhisperTek
installation
guide February
2016
2016 Nureva Inc.
All rights
reserved.dual
Nureva,
Span, WhisperTek
and the
Span logo are trademarks of Nureva Inc. in the United States, Canada and other countries.
18