Professional Documents
Culture Documents
Symptom: Canon Ir7095-Finisher Jam Code
Symptom: Canon Ir7095-Finisher Jam Code
Symptom: Canon Ir7095-Finisher Jam Code
Symptom
Error code E532, E566 and jam code 1320 are occurring alternately.
On the Finisher Fuse PCB at connector J413, 24 volts DC is measured at pin 2 to
ground and pin 3 to ground. Zero volts would be a normal reading at pin 2 to ground
and pin 3 to ground. The Finisher Fuse PCB had been replaced.
A resistance measurement of zero ohms at J413, pins 2 and 3 for the Stapler Safety
microswitches (MSW5 and MSW6) proved good.
Cause
In this case, a very high resistance was measured at J414 of the Finisher Fuse PCB
for microswitch MSW1 - the Finisher Front Door switch. A zero ohm resistance
measurement at J414 is a good reading.
Action
Replacing MSW1 (FM2-5751-000) resolved the service issue for the finisher.
Symptom
When the iR is powered on it displays a 1320 jam.
Cause
The 1320 jam is produced because the saddle stitch controller is missing 24vdc at
connector J203. The connection was loose at the rear of the saddle stitch unit. The
connector is at the cable holder. The connection is made through cable holder this
can be found on Figure Q13 item number 11 in the V1 / V2 parts manual.