Professional Documents
Culture Documents
FT1DR/DE Software Update Information
FT1DR/DE Software Update Information
After updating the MAIN software the DSP software must also be updated.
CAUTION:
Please be sure to confirm the model and the version of your transceiver before starting the update.
Writing incorrect firmware to the transceiver may cause abnormal operation or failure.
New Additional AMS Features. Refer to the Important change in AMS Feature.
A standby beep function has been added to make a pip sound when the received digital signal has
ended in a digital mode. The default setting is ON, but it can be turned off in the STANDBY
BEEP set mode.
Additional functions are improved and optimized.
NOTE: NOTE: When MAIN Software V2.04 is installed you must check the DSP Software version.
If you do not have V1.07 DSP Software, then it must also be installed at the same time (otherwise it
may not function correctly). Refer to the Help File to find how to check the Main and DSP software
version.
If you already have Main V2.04 and DSP V1.07 software versions, it is not necessary to update
the FT1DR/DE again.
We hope this new software will increase your enjoyment of your FT1DR/DE. Thank you for
choosing Yaesu radios. If you have any problems or questions please contact Yaesu Amateur
Tech Support amateurtech@yaesu.com.
Yaesu USA | 6125 Phyllis Drive | Cypress, CA 90630 | 714.827-7600 | FAX: 714.827-8100
http://www.yaesu.com