Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

Page 1 of 1

REV-06

Fastenal Product Standard

Date: December 23, 2014

DP.PULL.BF

Pins, Pull Dowel, Bright Finish


The information below lists the required dimensional, chemical and physical characteristics of the products in this purchase order. If
the order received does not meet these requirements, it may result in a supplier corrective action request, which could jeopardize your
status as an approved vendor. Unless otherwise specified, all referenced consensus standards must be adhered to in their entirety.

Nominal Thread
Size
Size
1/4
5/16
3/8
1/2
5/8
3/4
1

#8-32
#10-32
#10-32
1/4-20
1/4-20
5/16-18
3/8-16

B
Point
Diameter
Max.
0.237
0.299
0.362
0.480
0.605
0.725
0.975

a
S
Point
Drill
Pin Diameter
Length Length
Max.
Min.
Min.
Max.
0.2503 0.2501 0.030
0.455
0.3128 0.3126 0.034
0.575
0.3753 0.3751 0.037
0.575
0.5003 0.5001 0.045
0.660
0.6253 0.6251 0.045
0.660
0.7503 0.7501 0.058
0.785
1.0003 1.0001 0.058
0.785
Length Tolerance: +/- 0.010

T
Thread
Length
Min.
0.215
0.255
0.255
0.350
0.350
0.425
0.425

Specification Requirements:

Dimensions:
Material &
Mechanical Properties:
Thread Requirements:
Finish:

See Table Above


AISI 52100 Thru-hardened to 58 to 62 HRC.
Per ASME B1.1 Class 2B
Bright Finish

R
Radius
0.031
0.040
0.055
0.078
0.094
0.105
0.160

Double
Shear (lbf)
Min.
14,730
23,000
33,150
58,920
92.040
132,540
235,620

You might also like