Professional Documents
Culture Documents
Eigrp Quiz
Eigrp Quiz
Which multicast address does an EIGRP-enabled router use to send query packets?
224.0.0.10*
224.0.0.9
224.0.0.12
224.0.0.5
Which two protocols are allowed to be routed by EIGRP as a consequence of the PDM feature? (Choose two.)
Ipv4*
TCP
Ipv6*
UDP
RTP
In the command router eigrp 100, what does the value 100 represent?
the autonomous system number*
the router ID
the administrative distance
the metric
What address and wild card mask can be used to enable EIGRP for only the subnet 192.168.100.192 255.255.255.192?
192.168.100.192 0.0.0.7
192.168.100.192 0.0.0.15
192.168.100.192 0.0.0.63*
192.168.100.192 0.0.0.127
Refer to the exhibit. What does the value 2816 represent in the output display?
feasible distance
shortest distance
reported distance*
administrative distance
What two conditions will result in an EIGRP route going into the active state? (Choose two.)
One neighbor has not met the feasibility condition.
The router is not sending queries.
The successor is down.*
There is no feasible successor.*
The network has been recalculated.
Refer to the exhibit. EIGRP has been configured on all routers in the network. What is the reason for the route in the last line of the routing table to be
marked as D EX?
The route is in the "Active" state and will be removed from the routing table in 4 minutes and 23 seconds.
Refer to the exhibit. Which command was used to generate this output?
show
show
show
show
ip
ip
ip
ip
eigrp neighbors
eigrp topology all-links
eigrp traffic
protocols*
The key ID is invalid, because its value has to be in the range from 1 to 2147483647.
The routers have a different value for the key-string.*
The key chain name must be in upper case.
At least two keys had to be created for each key chain.
The EIGRP message authentication is being configured on the wrong interface on R2.*
A network administrator is analyzing the differences between an EIGRP hold timer and EIGRP hello interval. What statement
is valid about EIGRP hello and hold timers?
EIGRP hello intervals should be less than or equal to EIGRP hold timers.*
EIGRP hello intervals and hold timers must match between EIGRP neighbors to form an EIGRP adjacency.
EIGRP hold timers specify the minimum time that the router should wait to send the next hello.
EIGRP hello timers specify the maximum time that the router should wait to receive the next hello.
Which statement is true about EtherChannel technology?
All configuration tasks must be done on the individual ports in the EtherChannel link.
EtherChannel uses existing switch ports.*
Links must be upgraded to support EtherChannel.
STP does not run on redundant EtherChannel links.
Refer to the exhibit. An administrator tried to implement an EtherChannel between two switches by grouping the six physical ports as shown. However,
the administrator was not successful. What is the reason for that?
An
An
An
An
EtherChannel
EtherChannel
EtherChannel
EtherChannel
link
link
link
link
can
can
can
can
only
only
only
only
be
be
be
be
Refer to the exhibit. An administrator wants to form an EtherChannel between the two switches by using the Port Aggregation Protocol. If switch S1 is
configured to be in auto mode, which mode should be configured on S2 to form the EtherChannel?
On
auto
desirable*
off
Which two protocols are used to implement EtherChannel? (Choose two.)
Spanning Tree Protocol
Rapid Spanning Tree Protocol
Port Aggregation Protocol*
Link Aggregation Control Protocol*
Cisco Discovery Protocol
Which three interface parameters must match for an EtherChannel to form? (Choose three.)
allowed VLANs*
EtherChannel mode
native VLAN*
PortFast mode
spanning-tree state
trunking mode*
Identification
used to form an EIGRP neighbor relationship - hello
used to distribute routing information - update
used to confirm the reliable delivery of a packet - acknowledgment
used in response to an EIGRP-enabled router searching for a network reply
used to search for an alternate path query
IP
When an EIGRP-enabled router uses a password to accept routes from other EIGRP-enabled routers,
which mechanism is used?
bounded updates
partial updates
EIGRP authentication*
Diffusing Update Algorithm
Reliable Transport Protocol
If all router Ethernet interfaces in an EIGRP network are configured with the default EIGRP timers,
how long will a router wait by default to receive an EIGRP packet from its neighbor before declaring
the neighbor unreachable?
10 seconds
15 seconds*
20 seconds
30 seconds
Why would a network administrator use a wildcard mask in the network command when configuring a
router to use EIGRP?
to lower the router overhead
to send a manual summarization
to exclude some interfaces from the EIGRP process*
to subnet at the time of the configuration
Which EIGRP route would have the preferred administrative distance?
a summary route*
an internal route
an external route that is redistributed from RIP
an external route that is redistributed from OSPF