This document provides instructions for cutting holes in QUAZITE® enclosures using two methods: a masonry hole saw or a knockout punch driver. The masonry hole saw method involves drilling a 7/8" pilot hole with a carbide drill, then using a diamond tipped masonry hole saw to cut the hole, taking approximately 1-1.5 minutes. The knockout punch driver method involves setting up the punch by sliding the die over the pull rod, inserting the rod into the pilot hole, and threading the punch onto the rod, then punching the hole by operating the hand pump until penetration and removing the slug.
This document provides instructions for cutting holes in QUAZITE® enclosures using two methods: a masonry hole saw or a knockout punch driver. The masonry hole saw method involves drilling a 7/8" pilot hole with a carbide drill, then using a diamond tipped masonry hole saw to cut the hole, taking approximately 1-1.5 minutes. The knockout punch driver method involves setting up the punch by sliding the die over the pull rod, inserting the rod into the pilot hole, and threading the punch onto the rod, then punching the hole by operating the hand pump until penetration and removing the slug.
This document provides instructions for cutting holes in QUAZITE® enclosures using two methods: a masonry hole saw or a knockout punch driver. The masonry hole saw method involves drilling a 7/8" pilot hole with a carbide drill, then using a diamond tipped masonry hole saw to cut the hole, taking approximately 1-1.5 minutes. The knockout punch driver method involves setting up the punch by sliding the die over the pull rod, inserting the rod into the pilot hole, and threading the punch onto the rod, then punching the hole by operating the hand pump until penetration and removing the slug.
Enclosures: Masonry Hole Saw 1. Drill a 7/8 pilot hole with a carbide tipped masonry drill. 2. Drill hole using a diamond tipped masonry hole saw. This is the preferred method from engineering. Estimated drilling time is 1 - 1.5 minutes.
Knockout Punch Driver
installation
1. Set up the punch
1.01 Slide the die over the pull rod.
1.02 Insert pull rod into pilot hole.
1.03 Thread the punch onto the pull rod.
1.
2. Punch hole and remove
2.01 Operate hand pump until the punch
penetrates the surface.
2.02 Open pump release valve.
2.03 Remove the slug.
2.
NOTE:
UL Listed enclosures with holes retain their UL
Listing as long as the holes do not exceed more
than 25% of the area of each sidewall. This applies to both special order enclosures with holes cut at the factory and to enclosures with holes drilled in the field.