Professional Documents
Culture Documents
APPDX G.1 - Lab6 CLI
APPDX G.1 - Lab6 CLI
WIRELESS NETWORK
INB 47403
ROZIYANI BINTI RAWI
JUNE 2015 (2/2015)
Assessment
LAB 6
Weightage
2%
Assessment Components :
1. Lab sheet verify all connection and configuration. (5 Marks)
INSTRUCTIONS:
Configure Access Point using Command Line Interface (CLI).
Steps:
1. Connect all devices as shown in Figure 6.1
2. Reset the Access Point to Factory setting. ( refer to the attached
guideline on how to reset to factory setting)
3. Connect PC to the AP using console cable.
4. Configure the following items on the access point:
a. Configure IP address
Ap>en
Ap# config t
Ap (config)# interface ________________________________________
Ap (int _____)# ip address ____________________________________
b. Verify interface configuration:
AP# show running config
//identify all interfaces status.
c. Enable radio interface
APPENDIX G.1
Ap(config)# int dot11 radio___________________________________
Ap(
)# ____________________________________________
d. Set SSID
AP(config)#int dot11radio0
AP(config)# ssid ___________________________________
e. Set Authentication to access the SSID
AP(ssid)# authentication open
Question:
Can you see the configured SSID in your list of available
wireless network?
___________________________________________________________
Why? ______________________________________________________
How to solve it? ______________________________________________
f. Broadcast the SSID
AP(ssidx)# ___________________________________________________
Question:
After the changes done, can you see the configured SSID in
your list of available wireless network?
____________________________________________________________
APPENDIX G.1