Professional Documents
Culture Documents
RRH-C2 Installation Manual
RRH-C2 Installation Manual
RRH-C2 Installation Manual
Ed. 01
Installation Manual
.
.
,
.
, .
.
: 3 105 3 Document Center
442-600
:http://www.samsungdocs.co.kr
Call Center .
:1588-4141
Revision History
Edition
Date
00
2011. 05.
01
2011. 09. 04
Desciption
Initial Draft
Update
Warning
Changes or modifications not expressly approved by Samsung could void the user's authority to
operate the equipment
This equipment has been tested and found to comply with the limits for a Class A digital device,
pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection
against harmful interference when the equipment is operated in a commercial environment. This
equipment generates, uses, and can radiate radio frequency energy and, if not installed and used in
accordance with the instruction manual, may cause harmful interference to radio
communications. Operation of this equipment in a residential area is likely to cause harmful
interference in which case the user will be required to correct the interference at his own expense.
Table of contents
Revision History ___________________________________________________________________ I
1 .
1.1
1.2
Cable Connection_______________________________________________________ 7
2 .
Installation _____________________________________________________A-1
2.1
2.2
2.2.1
2.4
2.4.1
2.4.2
2.5
2.5.1
2.5.2
2.6
2.6.1
2.7.4
F.1
II
1. Before Installation
Fig1.1RRH-C2 Outlook
Capacity
This is the specification of RRH-C2.
Items
Specification
Air specification
FDD CDMA
Operating Frequency
Channel Bandwidth
1.25MHz/5MHz
Capacity
50 W 2 T
DU~RRH-C2 Interface
CPRI 4.0(Optic)
Holdover
24 hr
Input Voltage
This is the input voltage specification of RRH-C2. RRH-C2comply with UL60950 safety
regulations.
Items
Specification
Input Power
-48VDC
Power consumption(MAX)
RRH-C2
Weight(kg)
RRH-C2
Max 31 kg
Environment condition
Items
Criteria
Specification
Temperature
Humidity
10~95%
GR-487-CORE Sec.3.34.2
(Issue 2, April, 2002) R3-204
Altitude
GR-63-CORE Sec.4.1.3
Earthquake
Zone 4
GR-63-CORE Sec.4.4.1
GR-487-CORE Sec.3.35.6
Vibration
Office Vibration
GR-63-CORE Sec.4.4.4
Transportation Vibration
GR-487-CORE Sec.3.35.5
GR-63-CORE Sec.4.4.5
GR-487-CORE Sec.3.35.3
Noise
(sound
pressure level)
<65 dBA
EMI
GR-487-CORE Sec.3.29
FCC Title47 Part 15 Class B
GR-1089-CORE
EN 55022, EN 55024
EN 301 489
1.2
Cable Connection
[UADU]
[RF Antenna]
4) Power Cable
5) CPRI Cable
[Rectifier]
6) RET Cable
7) RF Cable
[MGB]
[TGB]
2) TGB Ground Cable
TGB and Ground Kit is required when over 7/8 in. Feeder
Line is used.
Fig1.3Cabling Diagram
1.1RRH-C2Connecting Cable
From
To
Frame
Grounding
TGB
MGB
Cable
2)
: AWG4/0, GV 95 mm21C
2) TGB Ground Cable
: AWG4/0, GV 95 mm21C
3) RRH-C2 Ground Cable
: AWG8, GV 6 mm21C
4) Power Cable
: AWG10, 4 mm22C-1
5) CPRI Cable
: Optic Cable(Single Mode)
6) RET Cable Assy
7) RF Cable (1/2 in. or 7/8 in. Feeder Line)
2.
Installation
RRU Grounding
Check
z Note
1.Equipment intended for installation in Restricted Access Location
2. Installation shall be in accordance with the applicable parts of Chapter 8 of ANSI/NFPA 70
A-1
Installation Diagram
A-2
2.4 Mounting
2.4.1
A-3
2.4.2
PoleMount Type
This explains how to install RRH-C2 to the pole
1) Assemble bracket to RRH-C2 (A)
2) Assemble the pole mount assy to the pole. (B)
3) Install RRH-C2 to the pole mount assy(C)
A-4
RF Antenna
RRH-
Fig2.9RRH-C2Feeder Line
A-5
A-6
Detail B
RF Antenna
Antenna Connector(Din-Female)
Din-Type Male Connector
for 1/2 In. Feeder Line
Heat Shrink Tube(Jelly Type)
A-7
RF
, pole
down Fig .
- : / 45
45
45
RF Antenna
A-8
RETConnector(SAMWOO, SU-20SP-8P)
Heat Shrink Tube(Jelly Type, Black)
RET Cable
Fig2.12RETCable Connection
A-9
Fig2.13RETCable Connector
2.3RETCable Connector Pin Map
RET
Samwoo, SU-20SP-8P
Pin
2.5.2
Function
RS485B
RS485A
+24 V RTN
1, 2, 8
NC
A-10
RRH-C2Grounding
RRH-C2 .
1) (AWG8, GV 6 1 C) 1 MGB RRH-C2
.
2) 6 heat shrink tube .
3) RRH-C2 ,
M6 SEMS .
6 Pressure Terminal
(d2: 16 mm, 90, 2 Hole)
Detail A
A-11
UL ,
.
Ex) Manufacture-Panduit
RRH-C2 : 6 mm2 Type Name(LCD8-14AF-L)
.
Inspection Window
.
A-12
Optic0
A-13
DC Power Cable
(AWG8 or AWG10,
11.5~15.5mm)
11.5 ~
15.5mm
70 mm
DC Power Cable
(AWG8 or AWG10,
11.5~15.5mm)
10 mm
60 mm
70 mm
DC Power Cable
(AWG8 or AWG10,
11.5~15.5mm)
A-14
DC Power Cable
(AWG8 or AWG10, 11.5~15.5mm)
A-15
A-16
2.7.4
Optic0
A-17
2.5CPRI Cable
Cable Color
Port
A-18
Blue
Orange
Green
Brown
Gray
Optic 0
Optic 1
Spare
Spare
Spare
(CDMA 0)
A. Standard Torque
Torque[kgf.cm]
Torque[N.m]
M3
4.59~5.61
0.45~0.55
M4
10.98~13.42
1.08~1.32
M5
21.15~15.85
2.07~2.54
M6
38.16~46.64
3.74~4.58
M8
91.8~112.2
9.01~11.01
M10
180~220
17.66~21.58
M12
307.8~376.2
30.20~36.91
A-19
B. Product Label
\
B-20
RRH-C2
2011 Samsung Electronics Co., Ltd.
All rights reserved.
.