Professional Documents
Culture Documents
Pin Out Conector AGC ODU
Pin Out Conector AGC ODU
Pin Out Conector AGC ODU
Connect the voltmeter to the BNC connector. Center pin is positive. Use a low voltage range
for best resolution, nominally 2.5 Vdc FSD.
2)
3)
Check and record the peak voltage at each end. The RSSI voltage provides a direct relationship with RSL,
as follows:
Units
BNC (Vdc)
0.25
0.5
0.75
1.0
1.25
1.5
1.75
2.0
2.25
2.5
RSL (dBm)
-10
-20
-30
-40
-50
-60
-70
-80
-90
-100
4)
Compare actual RSLs to the expected RSLs from the link installation datapack. Refer to par.
4.1.11.2.3.1 - RSL Measurement Guidelines.
5)
Note
Failure to replace the RSSI BNC weatherproof cap may result in damage to the ODU.
2)
3)
Check and record the peak voltage at each end. The RSSI voltage provides a direct relationship with RSL,
as follows:
Units
Service kit cable (Vdc)
RSL (dBm)
4)
4.71
4.12
3.5
2.9
2.3
1.71
1.11
0.59
0.14
-10
-20
-30
-40
-50
-60
-70
-80
-90
-100
Compare actual RSLs to the expected RSLs from the link installation datapack. Refer to par.
4.1.11.2.3.1 - RSL Measurement Guidelines.
User Manual
Installation
681/876
Connection table
Signal
M1
M2
ETH_TXP_T
ETH_TXN_T
GND
ETH_RXP_T
ETH_RXN_T
PRX_OUT
12
M3
M4
Connector usage:
banana plugs (M3) and (M4): output is a 0 to +5V DC voltage proportional to the radio Rx field.
Duringequipment lineup, through a multimeter it is possible to easily point the antenna until the
measuredvoltage is the maximum, corresponding to the maximum radio Rx field.
User Manual
Installation