Professional Documents
Culture Documents
Lexmark C 510
Lexmark C 510
www.uninetimaging.com
2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact techsupport@uninetimaging.com
Part Number
20K1403
20K1400
20K1401
20K1402
20K0505
20K0504
20K0503
20K0500
20K0501
20K0502
Stated Yield
10,000
6,600
6,600
6,600
12,000
60,000
5,000
3,000
3,000
3,000
All four of the toner cartridges are different in that they each have unique tabs (see above photos) on the side that prevent one
color from being inserted into another colors slot.
www.uninetimaging.com
2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact techsupport@uninetimaging.com
REQUIRED TOOLS
1. Toner approved vacuum
2. Phillips head screwdriver
3. Small jewelers Phillips screwdriver
4. Soft lint-free wipes
REQUIRED SUPPLIES
1. Toner for Lexmark C510 (310g black, 210g color)
2. Developer roller cover
1. Remove the two silver screws from the outer edge of the
doctor blade.
3. Dump out all remaining toner from the chamber. The fill plug
in these cartridges is not removable. Blow out any remaining
toner from the hopper paying special attention to the feed
roller. It can become clogged (impacted) with toner and over
time this will interfere with the amount of toner fed to the
developer roller
www.uninetimaging.com
2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact techsupport@uninetimaging.com
4. Make sure the gears on both sides of the cartridge are clean and turn freely.
6. Fill the hopper with the appropriate color toner. While the
cartridges all look the same, they are not interchangeable.
Each color has a different set of plastic tabs.
www.uninetimaging.com
2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact techsupport@uninetimaging.com
7. Install the developer roller assembly small gear to the fill plug side of the cartridge.
Install the outer screws. NOTE: Make sure the black tab is facing forward (as shown).
www.uninetimaging.com
2010 UniNet Imaging Inc. All trademark names and artwork are property of their respective owners. Product brand names mentioned are intended to show compatibility only.
UniNet Imaging does not warrant downloaded information. Unauthorized sale, reproduction or distribution of this article is prohibited. For additional support, please contact techsupport@uninetimaging.com