Professional Documents
Culture Documents
12 - WellTec - Gary Tait
12 - WellTec - Gary Tait
12 - WellTec - Gary Tait
Presented by:
Date:
Most common reason for not being able to pull the Crown
GS Pulling tool
Crown Plugs
Well Stroker
2 1/8 to 5 1/2
21 ft*
220 lbs*
>2.2
7 liters/section
Removing obstructions
Well Miller
Circulation holes
Hydraulic Puncher, none explosive
Plug setting
Plug Setting Tool, none explosive
General Description
Electro Hydraulic operational setting tool for plugs, packers and straddle
systems
The tool requires no form of explosives or pre-charge of pressure and is
not dependent on well pressure for operation
The WST can be used to set any plug run on Baker #20 E4 setting tool
Technical Description
Make up length: 4,2 m
Maximum OD: 3 7/8
Maximum stroke length: 14
Maximum stroke force: 55.000 lbf
Maximum operational temp: 135 C
Maximum well pressure: 10.000 psi
Setting sleeve connection: Running tool/plug connection:
-
*The stroke force can be doubled to 110.000 lbf by adding one piston stage to
the tool
The increased tool length will be 60 cm
Cut tubing/casing
The Welltec Cutter is a tool that enables efficient, safe drill pipe and casing recovery operations
without the need for explosives. It is self-centralizing and removes pipe incrementally so that no
shavings are generated and a smooth, polished surface remains after the cut.
The Welltec Cutter eliminates the need for explosives required by most of the industry
alternatives. Explosives can pose an operational risk, especially when simultaneous operations
are being conducted. Transfer of explosives may also cause additional logistical requirements
and significant operational delays.
Cut examples
Cutter head
10
Welltec Cutter
Well Cutter
4.5 5.5 Drillpipe, casing or tubing
13
14
30
20
10
5
0
Reservoir
PST to remove debris on top of crown plug, sand fill, swarf, metal or rubber, etc.
Cleaning services to remove debris, sand fill, swarf, metal or rubber, etc. to obtain access
for other operations
Well Stroker to verify top of cement plug integrity (10-16 ton force)
Logging, inspection and verification of annulus cement, pipe integrity and potential leaks
in conjunction with 3rd party
Questions