This document discusses isometric and orthographic projections used in engineering drawing. It provides instruction on how to draw isometric views of objects by projecting them at 30 degree angles and labeling the 3 principal views. Orthographic projections are also covered, explaining how to draw objects in 2-dimensional side views by projecting parallel lines rather than at an angle.
This document discusses isometric and orthographic projections used in engineering drawing. It provides instruction on how to draw isometric views of objects by projecting them at 30 degree angles and labeling the 3 principal views. Orthographic projections are also covered, explaining how to draw objects in 2-dimensional side views by projecting parallel lines rather than at an angle.
This document discusses isometric and orthographic projections used in engineering drawing. It provides instruction on how to draw isometric views of objects by projecting them at 30 degree angles and labeling the 3 principal views. Orthographic projections are also covered, explaining how to draw objects in 2-dimensional side views by projecting parallel lines rather than at an angle.
This document discusses isometric and orthographic projections used in engineering drawing. It provides instruction on how to draw isometric views of objects by projecting them at 30 degree angles and labeling the 3 principal views. Orthographic projections are also covered, explaining how to draw objects in 2-dimensional side views by projecting parallel lines rather than at an angle.