Meet or Exceed OSHA Requirements

You might also like

Download as docx or pdf
Download as docx or pdf
You are on page 1of 2

Meet or Exceed OSHA 

Requirements
April 7, 2010 — Kirk Edwards

EXAIR pays very close attention to providing safe products for the operators of our products.

We pay particular attention to a couple of OSHA’s standards; CFR 1910.242 (b) and 29 CFR

1910.95 (a).

OSHA Standard CFR 1910.242(b) deals with compressed air for cleaning and states the following;

Compressed air shall not be used for cleaning purposes except where reduced to less than 30 p.s.i.

and then only with effective chip guarding and personal protective equipment.

More specifically to the standard OSHA states “ The only restriction on air pressure is that, on dead-

ending the exit orifice, the static pressure shall be less than 30 PSI.” That is where EXAIR comes in,

we have engineered all of our blow off products so that there an alternate route for any air flow which

may be blocked to go. There is an alternative pathway for the air to flow through if it is somehow

blocked, thus no possibility for dead ending.

This design meets the OSHA standard and also allows operators to maintain full pressure through a

manifold, air line or air gun which produces the highest velocity to do better work when compared to a

regulated air gun or a lower pressure. Of course we always recommend proper eye protection and

safety gear when there is potential for chips and debris to fly around an operator.

With the exception of our largest Super Air Nozzles – All of our products fall well below any decibel

threshold which would require hearing protection. In fact we manufacture some of the quietest

compressed air products in the world. The chart found at this link shows maximum allowable noise

exposure according to OSHA 29 CFR- 1910.95 (a).

You will see EXAIR publishes noise levels for any product blowing directly into a work environment.

These noise levels are all measured 3 feet away from the product orifice at a 90 degree angle to the

orifice in our testing facility, ensuring true and accurate information. And we also note any product

which exceeds this OSHA standard and state the exposure time allowed to their sound level. And

again we recommend hearing protection when necessary.

©Copyright 2010 EXAIR Corporation


EXAIR products can help you meet or exceed these OSHA requirements. Let us help you before OSHA

gets to you.

11510 Goldcoast Drive


Cincinnati, OH 45249
TecHelp@EXAIR.com

You might also like