The document provides steps to create an embossed text on a cylindrical surface in a 3D modeling software. It involves first creating a cylinder, then using a sketch to add text on the front plane. An offset is used to extrude the text out from the surface at an angle to create an embossed effect. The draft feature is used and previewed before completing.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as PPT, PDF, TXT or read online from Scribd
The document provides steps to create an embossed text on a cylindrical surface in a 3D modeling software. It involves first creating a cylinder, then using a sketch to add text on the front plane. An offset is used to extrude the text out from the surface at an angle to create an embossed effect. The draft feature is used and previewed before completing.
The document provides steps to create an embossed text on a cylindrical surface in a 3D modeling software. It involves first creating a cylinder, then using a sketch to add text on the front plane. An offset is used to extrude the text out from the surface at an angle to create an embossed effect. The draft feature is used and previewed before completing.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as PPT, PDF, TXT or read online from Scribd
The document provides steps to create an embossed text on a cylindrical surface in a 3D modeling software. It involves first creating a cylinder, then using a sketch to add text on the front plane. An offset is used to extrude the text out from the surface at an angle to create an embossed effect. The draft feature is used and previewed before completing.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as PPT, PDF, TXT or read online from Scribd
ON FRON PLANE USING SKETCH THE BOTTOM RIGHT 1. CREATE A CYLINDER OF CURVE FEATURE CORNER REQUIRED SIZE.
4. SELECT ONE OF THE
CYLINDRICAL SURFACES 6. SELECT “WITH DRAFT FEATURE” 5. GO TO EDIT MENU AND THEN SELECT OFFSET 7. ENTER THE DEPTH VALUE, OFFSET ANGLE (IF REQD.) AND THEN PRESS DEFINE. 8. SELECT FRONT AS YOUR SKETCH PLANE.SELECT “USE ALL THESE ARE AVAILABLE EDGE” OPTION TO SELCT THE TEXT CREATED IN STEP 2. IN REFERENCES TAB. COME OUT OF SKETCHER BY CLICKING THE TICK MARK
8. SEE THE PREVIEW. INCASE THE
PROJECTION IS NOT AS PER THE 9. THE EMBOSSED TEXT ON A CYLINDRICAL INTENTION, FLIP THE ARROW AND SURFACE IS READY !! ADJUST THE DIRECTION OF FLIP. COMPLETE THE FEATURE BY CLICKING THE GREEN TICK MARK