Professional Documents
Culture Documents
2GK LVA0701 en
2GK LVA0701 en
2GK LVA0701 en
type LOVOS
Instruction manual for installation and maintenance LVA/07/01/E
WARNING! It is necessary to obey the local regulations in this matter in country, where surge arresters
are installed.
Max. 10 Nm
Max. 10 Nm
Worning! When selecting accessories please take into consideration, that it is not allowed to cause any
mechanical stresses during mounting the arresters between phase and earth or between phases.
After selection suitable accessories, it is necessary to install surge arresters possibly nearest of protected object with
possible lowest of earthing impedance.
Top accessories are mounted on screw outlet of surge arrester. Accessories no. cat. 1701, 1702, 1704 and 1706 by
winding up without any additional coupling elements, no. cat. 1703 with washer and nut, which are included to the kit,
and no. cat. 1705 after screwing the sleeve.
Top accessories no. cat. 1705 are mounted to insulation line with the torque up to break the nut.of the bolt.
Bottom accessories (earthing) are mounted to the hole of the earthing outlet of surge arrester by using the kit: bolt,
washer and nut. Earthing conductors of surge arresters with disconnector should be flexible with terminals
(no. cat. 2711-2718) and should be shaped in form of letter “U”, in order to help of action the disconnector (throwing
away the earthing outlet from the housing).
MAINTENANCE
Surge arresters type LOVOS don't require the special maintenance. After bigger storms with discharges, it is
recommended to pay attention to outward appearance of surge arresters. The best way to do it, is by the using of
binoculars. Damaged surge arresters or these, in which the disconnector was operated should be replaced with new
one. After operating the disconnector, there is the earthing outlet outside the housing with visible red colour.
WARNING! It is necessary to obey the local regulations in this matter in country, where surge arresters were installed.
RECYCLING
Surge arresters, because of using raw materials and technology, aren't dangerous for the environment.
Broken-down product should be disassembled with filing steel parts, non-ferrous metal parts and rubber.
Arrester housing should be broken by the hit of the hammer, surge arrester should lie on the metal sheet and should be
wrapped around in linen fabric or other material in order to avoid the splinters. Next, should be filed the metal parts, ZnO
block, graphite washers and damaged housing polyamide parts.
Filed metal parts, broken polyamide parts, rubber parts and graphite washers should be given for recycling or utilisation
to suitable companies.
ZnO blocks should be given to “EKOPUR” Company Zgierz (Poland) tel. +48 (0) 42 716 95 90, e-mail: ekopur@iq.pl
or to other choosing company.
SPARE PARTS
Deliveries of spare parts, and repairs of surge arresters aren't foreseen.
REQUIREMENTS
Surge arresters type LOVOS (GX0-LOVOS) meet the requirements of polish standard PN-IEC 61643-1 and
international standard IEC 61643-1 class II standard DIN/VDE 0675/6 class A and Amendment 2 to IEC 60099-4 in
relevant range. Publication 03.2002
ABB Sp. z o. o.
Branch in Przasnysz
ul. Leszno 59
06-300 Przasnysz, Poland
Phone: +48 29 75 33 200
Sales Office +48 29 75 33 223, 75 33 227, 75 33 222
Fax.: +48 29 75 33 329, 75 33 328
www.abb.com