Professional Documents
Culture Documents
Ccna 2 Final 4.1
Ccna 2 Final 4.1
FTPS
HTTP
** HTTPS
WEP2
TFTP
2 Refer to the exhibit. A new branch office has been added to the corporate network and a new router is to be
installed to allow branch office users to access the database server at headquarters. How should the serial
0/0/0 interface of the new branch office router be configured to connect to the headquarters router?
branch_23(config-if)# no shutdown
branch_23(config-if)# encapsulation ppp
branch_23(config-if)# ip address 192.168.5.33 255.255.255.240
3Which two commands ensure that any password that permits access to the privileged EXEC mode is not
shown in plain text when the configuration files are displayed? (Choose two.)
4A new network is to be configured on a router. Which of the following tasks must be completed to configure
this interface and implement dynamic IP routing for the new network? (Choose three.)
6 A network administrator is asked to design a system to allow simultaneous access to the Internet for 250
users. The ISP for this network can only supply five public IPs. What can be used to accomplish this task?
routable translation
dynamic translation
static translation
** port address translation
** BGP
RIP
OSPF
EIGRP
8 Refer to the exhibit. The network administrator needs to configure the router with a name. Which command
will the administrator use to configure the router name?
to indicate the correct router interface that should be used to forward a segment
to identify which switch ports should receive or forward the segment
** to determine which Layer 3 protocol should be used to encapsulate the data
to enable a receiving host to forward the data to the appropriate application
to allow the receiving host to assemble the packet in the proper order
11Which two statements are true about the use of the debug ip rip command on a Cisco router? (Choose two.)
** The debug ip rip command displays RIP routing activity in real time.
**The debug ip rip command can be issued at the user EXEC configuration mode.
The debug ip rip command displays a combination of the information that is displayed by the show ip route and
show ip protocols commands.
Because of router processor usage, the debug ip rip command should be used only when necessary.
The debug ip rip command should be used instead of the show ip route command whenever possible.
12What minimum configurations must be set on a host to allow a request to be sent to http://www.cisco.com/?
(Choose four.)
**DNS server
WINS server
**IP address
NetBIOS
** subnet mask
** default gateway
13A Catalyst 2960 switch has been taken out of storage to be used as a temporary replacement for another
switch that needs to be repaired. About a minute after the switch has started, the SYST LED on the front of the
switch transitions from blinking green to amber. What is the meaning of the amber SYST LED?
15After an unsuccessful ping to the local router, the technician decides to investigate the router. The technician
observes that the lights and fan on the router are not operational. In which layer of the OSI model is the
problem most likely occurring?
transport
network
data link
** physical
17Refer to the exhibit. The network shown is connected using services from the same ISP. How will the Fohi
router dynamically learn routes to the 192.168.16.16/28, 192.168.16.32/28, and 192.168.16.64/28
subnetworks?
with BGP
**with a static route
with a directly connected route
with an interior routing protocol
18Refer to the exhibit. Which type of UTP cable should be used to connect Host A to Switch1?
rollover
console
crossover
**straight-through
19When customers use credit cards to make purchases at a small business, a modem is heard dialing a
telephone number to transfer the transaction data to the central office. What type of WAN serial connection is in
use?
leased line
packet switched
** circuit switched
point-to-point
20 A user reports being unable to access the Internet. The help desk technician employs a bottom-up approach
to troubleshooting. The technician first has the user check the patch cable connection from the PC to the wall,
and then has the user verify that the NIC has a green link light. What will the technician have the user do next?
Enter an IP address into the WWW browser address bar to see if DNS is at fault.
Use traceroute to identify the device along the path to the ISP that may be at fault.
** Verify the IP address, subnet, and gateway settings using ipconfig on the PC .
Connect to the user home router to check firewall settings for blocked TCP ports.
21 A ping 192.1.1.20 command is issued on workstation A to determine if workstation B can be reached. What
events will occur if this command is successful? (Choose two.)
** The data conversation was started by the HTTP application process running on the client.
The data conversation is identified by TCP port 80 on the client.
The user started the data conversation by sending an e-mail.
The IP address of the Internet server is 192.168.17.43 .
**The Internet server will send data to port 8547 on the client.
sending echo requests from the source to the destination host to establish the presence of the destination
determining the IP address of the destination host in preparation for data transfer
requesting the destination to transfer a binary file to the source
**synchronizing sequence numbers between source and destination in preparation for data transfer
host address
network address
**broadcast address
multicast address
26A customer reports connectivity problems to an ISP technician. Upon questioning the customer, the
technician discovers that all network applications are functioning except for FTP. What should the technician
suspect is the problem?
** misconfigured firewall
bad port on switch or hub
misconfigured IP addressing on the customer's workstation
wrong DNS server configured on the customer's workstation
wrong default gateway configured on the customer's workstation
27The show ip route command was executed on one of the routers shown in the graphic and the following
output was displayed:
C 192.168.4.0/24 is directly connected, Serial0/0
R 192.168.5.0/24 [120/1] via 192.168.4.2, 00:00:19, Serial0/0
R 192.168.1.0/24 [120/2] via 192.168.3.1, 00:00:20, Serial0/1
R 192.168.2.0/24 [120/2] via 192.168.3.1, 00:00:20, Serial0/1
C 192.168.3.0/24 is directly connected, Serial0/1
From which router was this command executed?
A
B
C
D
28Refer to the exhibit. Which two sets of commands are required to configure passwords for all management
ports on a Catalyst 2960 switch? (Choose two.)
ALSwitch(config)# interface vlan 1
ALSwitch(config-if)# password cisco
ALSwitch(config-if)# login
30Refer to the graphic. Which command will configure a static route on Router A to direct traffic from LAN A
that is destined for LAN C?
31Which subnet masks could be used when subnetting a Class B IP address? (Choose two.)
255.255.255.240
** 255.255.192.0
** 255.255.0.0
255.192.0.0
240.0.0.0
255.0.0.0
32 Refer to the exhibit. The network administrator has configured the RTA and RTB interfaces. In order to allow
hosts that are attached to RTA to reach the server that is attached to RTB, a static route from RTA to the
server LAN and a default route from RTB back to RTA need to be configured. Which two commands will the
administrator use to accomplish these tasks on the two routers? (Choose two.)
33How do port filtering and access lists help provide network security?
**They prevent specified types of traffic from reaching specified network destinations.
They alert network administrators to various type of denial of service attacks as they occur.
They prevent viruses, worms, and Trojans from infecting host computers and servers.
They enable encryption and authentication of confidential data communications.
34 Refer to the exhibit. The network administrator of the building in the graphic needs to choose the type of
cable best suited to add ServerB to the network. Which cable type is the best choice?
STP
UTP
coaxial
**fiber optic
35What is used by a routing protocol to determine the best path to include in the routing table?
Convergence time
Default distance
** Metric
Type of router
36Refer to the exhibit. Which IP addresses could be assigned to the hosts in the diagram? (Choose two.)
192.168.65.31
192.168.65.32
** 192.168.65.35
** 192.168.65.60
192.168.65.63
192.168.65.64
37Given the network 192.168.25.0 shown in the graphic, which subnet mask would accommodate the number
of hosts in each subnet?
255.255.0.0
255.255.224.0
255.255.255.0
** 255.255.255.224
255.255.255.240
255.255.255.248
38 Which two protocols allow network devices to report their status and events to a centralized network
management device? (Choose two.)
** Syslog
Telnet
HTTP
HTTPS
** SNMP
PAT uses the word "overload" at the end of the access-list statement to share a single registered address.
Static NAT allows an unregistered address to map to multiple registered addresses.
Dynamic NAT allows hosts to receive the same global address each time external access is required.
**PAT uses unique source port numbers to distinguish between translations.
40Refer to the exhibit. The graphic shows the output of a command issued on router RTB. According to the
output, what two statements are true of router RTB? (Choose two.)
41Refer to the exhibit. The network administrator uses the command below to configure a default route to the
ISP network :
RTB(config)# ip route 0.0.0.0 0.0.0.0 10.1.1.6
A ping issued from the ISP is successful to router RTB. However, ping echo request packets arrive at a host
that is attached to the Fa0/0 interface of RTB, and the replies do not make it back to the ISP router. What will
fix this problem?
The ISP must be configured to forward packets from the 192.168.1.0 network.
**The ip route command needs to be edited so that the next hop address is 10.1.1.5.
The ip route command needs to be edited so that the 192.168.1.1 address is the next hop address.
The ip route command should be removed from the RTB router configuration.
42 A network technician is using a network management station to gather data about the performance of
devices and links within the ISP. Which application layer protocol makes this possible?
**SNMP
FTP
DHCP
SMTP
an IDS
**an IPS
a host-based firewall
Anti-X software
45 How many host addresses may be assigned on each subnetwork when using the 130.68.0.0 network
address with a subnet mask of 255.255.248.0?
30
256
**2046
2048
4094
4096
46In an IPv4 environment, what information is used by the router to forward data packets from one interface of
a router to another?
47 A small tire retailer requires a low-cost WAN connection to its headquarters in order to manage its inventory
and process customer sales in real time. Which WAN connection type is best suited to its needs?
Sonet
T3
**dialup
DSL
leased line
48The command copy tftp running-config has been entered on the router. What will this command do?
49Refer to the exhibit. The network administrator needs to configure the Fa0/0 interface of RTB so that hosts
from RTA can connect to the server that is attached to RTB. Which two commands will the administrator use to
accomplish this task? (Choose two.)
50Refer to the exhibit. A NOC technician at an ISP enters the command shown. What are two reasons to use
this command? (Choose two.)