Professional Documents
Culture Documents
TTSL Orissa EGPRS Download Throughput Improved-New
TTSL Orissa EGPRS Download Throughput Improved-New
This parameter represents whether BSC supports signaling uplink extended TBF. Normally, the
uplink signaling message transmission was finished, uplink TBF link was released immediately to
free TFI resource. Uplink signaling extended TBF enabled can hold the link and TFI resource for
some time, if MS needs transmission signaling again, it can use the TFI resource. The uplink TBF
established constantly will affect downlink throughput.
Value range: Check/Uncheck
Check: Support signaling uplink extended TBF Uncheck: Does not support signaling uplink
extended TBF
Default value: Uncheck,
Suggestion value: Check
TBF(Cell)
This parameter represents whether extended uplink TBF is supported in the cell.
If support extended uplink TBF, after uplink TBF link have sent last RLC data block, the link
don’t release for short time, if there have data to send, the link will be used, new TBF link
establishment is not necessary, it save the time to load data.
If Mobile is in data service and does Cell Reselection, the MS will stop data transmission about 4-
10seconds. In order to decrease cell reselection, need to increase the ReselHysteresis parameter to
avoid cell reselection frequently.
6. Edge Params(Cell)
In report mode, 0 means report based on TBF, 1~3 means report based on timeslot(BURST).
Currently in report based on timeslot, omission of report occurs at some terminals, which seriously
affects adjustment of coding mode(MCS1-9)
Value Range: Average filter period for downlink BEP {0, 1, 2, 3, 4, 5, 6, 7, 8, 9, 10, 11, 12, 13,14,
15}, Average filter period for uplink BEP {0, 1, 2, 3, 4, 5, 6, 7, 8, 9, 10}
Default value: both are 4 blocks.
Suggestion value: both are 10 blocks.
GPRS MAX initial access signal level set to 5 for GSM900MHz, set to 2 for DCS1800MHz.
Suggestion value: Changing it from 5 to 2.
Level) changed
Level) changed
In order to give effective control, we will change the Site parameter of Bandwidth Limit(kb)
as below.
5) PDTCH Utillization
C900040140/ C900040136
We had defined above formula and exported performance data, and found the UPPB-DSP have
congestion for some cells.
BSC ID SITE ID Bts ID local cell UPPB DSP Belong to
ID Resource DSP No
Congestio
n Rate%
1 8 2 30172 5.81% 11
1 48 1 30461 50.00% 11
1 22 1 30351 12.50% 10
1 39 2 30522 5.88% 11
1 89 3 30933 6.67% 14
1 24 3 30233 8.57% 10
1 24 3 30233 5.95% 10
1 21 3 30593 12.82% 10
1 43 3 30513 7.69% 11
1 48 3 30463 5.56% 11
1 21 3 30593 18.18% 10
1 40 4 30384 12.50% 11
1 71 3 33243 20.00% 13
1 77 3 33043 5.26% 11
1 21 3 30593 8.45% 10
1 8 3 30173 11.36% 11
1 21 3 30593 17.24% 10
1 74 2 33422 25.00% 13
1 8 2 30172 10.34% 11
1 35 1 30341 8.11% 11
1 38 1 30061 16.00% 11
1 39 1 30521 9.09% 11
1 43 3 30513 6.67% 11
1 6 1 30211 5.56% 11
1 27 2 31582 6.25% 11
1 47 3 30453 7.14% 11
1 6 1 30211 8.70% 11
1 90 1 30811 12.50% 14
1 24 3 30233 5.88% 10
From OMCR we can export Network Planning Data table, and fond DSP No. the cell belong to.
From above table, we can statistic how many sectors connected to the DSP.
DSP NO. Total Sector
Numbers
0 1
So we suggest move above DSP congestion cells to DSP 15,19,21,22 to balance the DSP
process loading.
Moved
The Dynamic TS property used to provide more PDTCH to support data transmit, if the TCH
channel is enough to support voice service, the system will shift to dynamic TCH timeslots to
PDTCH. The shift action will happen at the before or back TCHs at the static PDTCH channel.
If you configure as below figuration, the system only shift the before dynamic TCH timeslots
to PDTCH, for this case, some shift actions will failure, because the USF flag bit can’t be moved
to other PDTCHs.
So we suggest move the static PDTCH to the middle between the TCHs with Dynamic TS,
the system is easy to shift the back or forth TCHs with dynamic TS property to PDTCH. The
configuration is as below.
Figure: the Dynamic TS property can shift both the back or forth TCH to PDTCH.
We configure the PDTCH to the site with both GPRS and EGPRS supported, if they shared
the PDTCH, the modulation of data coding will use GMSK to transfer data, that means the
subscriber with 8-PSK will change its modulation to GMSK, so the throughput of the subscriber
with 8-PSK will be decreased. The configuration is just as below.
Figure: the subscribers of both GPRS and EGPRS will share the PDTCH to transfer data.
Because the PS Service Preference Property is set to No Preference, the subscribers of both
GPRS and EGPRS will share the PDTCH to transmit data, the modulation will use GMSK to code
data, the throughput will be lower.
So we must change the configuration to support GPRS and EGPRS subscribers separately, the
subscribers to occupy the different PDTCH, just like below two figurations.
Above figuration indicates the subscribers of EGPRS will occupy the PDTCH with EDGE
Dedicated Property. If the C/I is enough better to support the 8-PSK coding, the coding set of data
transfer will use MCS-5 to MCS-9, so the throughput will be increased.
In order to support the GPRS subscribers, we will configure the GPRS preference PDTCH to it,
just like below figuration.
Figure: the subscribers of GPRS occupy the PDTCH with GPRS Preference Property.
So there have 3 PDTCH to support data transfer, the 2 PDTCHs are with EDGE dedicated and 1
PDTCH is with GPRS preference property in one sector.
PDTCHs
After adjust above parameters and reconfiguration, the Mean Rate of EGPRS LLC DownLink
Throughput of summarization from 7:00 to 24:00 by Cell is improved as below.
17 un
18 un
19 un
20 un
un
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
10
2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010-
6- 10 6- 11 6- 12 6- 13 6- 14 6- 16 6- 17 6- 18 6- 19 6- 20
Mean Rat e of EGPRS LLC DL 137102133549136841143349143093120059168660175706161752200255
t hroughput ( kbps)
Figure: BSC9 of Mean Rate of EGPRS LLC Downlink Throughput improved.
un
un
un
un
un
un
un
un
un
un
un
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
10
11
13
14
16
17
18
12
15
19
20
2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010-
6- 10 6- 11 6- 12 6- 13 6- 14 6- 16 6- 17 6- 18 6- 19 6- 20
Mean Rat e of EGPRS LLC DL 181297 185345 178324 185145 180824 147880 187513 196694 192351 197421
t hroughput( kbps)
Figure: BSC7 of Mean Rate of EGPRS LLC Downlink Throughput improved.
Before we have added one more PDTCH to support data with GPRS preference property in
one sector, so one TCH is decreased to support voice call in one sector. In order to avoid the
customer have complaint for the TCH decreased, we have changed one PDTCH with EDGE
dedicated channel to TCH channel. So in one sector there has only 2 PDTCH support data transfer,
the configurations are as below.
Before changing, in one sector there have 2 PDTCH support EDGE mobile and 1 PDTCH
support GPRS mobile.
After changing, in one sector there have only 1 PDTCH support EDGE mobile and 1 PDTCH
support GPRS mobile.
PDTCHs
After changing from 3 PDTCH channels to 2 PDTCH channels in one sector, the Mean Rate of
EGPRS LLC DownLink Throughput of summarization from 7:00 to 24:00 by Cell is same as
below.
un
un
un
un
un
un
un
un
un
un
un
un
un
un
un
un
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
13
18
23
10
11
12
14
15
16
17
19
20
21
22
24
25
2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010-
6- 10 6- 11 6- 12 6- 13 6- 14 6- 16 6- 17 6- 18 6- 19 6- 20 6- 21 6- 22 6- 23 6- 24 6- 25
Mean Rat e of EGPRS LLC DL 137102 133549 136841 143349 143093 120059 168660 175706 161752 200255 167678 166143 160242 161366 162500
t hr oughput ( kbps)
Figure: BSC9 of Mean Rate of EGPRS LLC Downlink Throughput.
un
un
un
un
un
un
un
un
un
un
un
un
un
un
un
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
-J
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010- 2010-
6- 10 6- 11 6- 12 6- 13 6- 14 6- 16 6- 17 6- 18 6- 19 6- 20 6- 21 6- 22 6- 23 6- 24 6- 25
Mean Rat e of EGPRS LLC DL 181297 185345 178324185145 180824 147880 187513 196694192351 197421 188743 189510 182875189102 197509
t hr oughput ( kbps)
Figure: BSC7 of Mean Rate of EGPRS LLC Downlink Throughput.
250000
230000
210000
190000
170000
150000
un
un
un
un
un
un
un
un
-J
-J
-J
-J
-J
-J
-J
-J
21
22
18
19
20
23
24
25
2010- 6- 18 2010- 6- 19 2010- 6- 20 2010- 6- 21 2010- 6- 22 2010- 6- 23 2010- 6- 24 2010- 6- 25
Mean Rat e of EGPRS LLC DL 190840. 77 239575. 66 257611. 73 251368. 63 246125. 03 244249. 74 236479. 53 244116. 71
t hr oughput ( kbps)
Figure: BSC6 of Mean Rate of EGPRS LLC Downlink Throughput.
Throughput
After changing above parameters and balance the DSP configuration, we have got best download
throughput.