Professional Documents
Culture Documents
Kta 38 M 0
Kta 38 M 0
M A R I N E
5 5 9 - 6 3 3 K W
7 5 0 - 8 5 0 H P
ENGINE S P E C I F I C AT I O N S
POWER R AT I N G S
S TA N D A R D F E AT U R E S Lubrication System
Marine-grade oil pan (114 L [30 gal]) or high capacity (185 L
Engine Design [49 gal]) available. Fleetguard spin-on filter cartridge for
Four cycle design for quiet and fuel-efficient operation. simplified service.
Low profile for ease of installation and service. Electrical System
Replaceable wet cylinder liners for longer life and lower 24-volt standard electrical system with 12-volt available.
rebuild cost. Oil cooled pistons for added durability. Standard alarm/switches for low oil and high water temperature
Cooling System for safe operation. Marine grade wiring harness.
Keel cooled or engine mounted heat exchanger for IMO Emissions Certified
reduced installation cost and complexity. Spin-on Fleetguard® Certificates of compliance available from the U.S. EPA and
water treatment filter. Lloyd’s Register of Shipping.
Air System
Twin Holset turbochargers optimized for marine use. AVA I L A B L E ACCESSORIES
Marine grade air filters with air inlet restriction included. Dry Front Power Take-Off
exhaust manifold with water shielding for reduced fuel Available Accessory Drives belt or gear driven
consumption and improved emissions. Centinel Oil Management System reduces oil and filter disposal
Fuel System costs
Dependable Cummins PT® fuel system can be operated Eliminator System replaces all lube oil cartridges
mechanically or with CENTRY® electronics for enhanced Prelub® Starter protects engine against damage from
engine fueling. Step Timing Control (STC) allows for smooth dry starts and extends engine life
engine acceleration under load. Spin-on Fleetguard filters or Classification Society Approvals: consult your
optional duplex Fleetguard fuel filters. local Cummins professional for a complete listing
of current marine agency approvals for this engine
KTA38-M0
M A
A R
R II N
N E
E
5
3 5
6 9
0 -
- 6
5 3
2 3
5 K
H W
P
7
2 5
6 0
9 -
- 8
3 5
9 0
2 H
KWP
W L
ENGINE DIMENSIONS
Length Width Weight Height
mm in mm in kg lb mm in
H
2003 79 1465.6 57.7 4222 9300 KC 2055.5 80.92
HX 1803.2 70.99
PERFORMANCE D ATA
Rating Continuous Duty 750 bhp* Continuous Duty 800 bhp*
Rating Definitions
Ratings are based on ISO 8665 conditions of 100kPa(29.612 in Hg) and 25°C (77°F) and 30%
relative humidity. Propeller shaft power represents the net power available after typical gear
losses and is 97% of rated power. Power rated in accordance with IMCI procedures.
Continuous Duty
Intended for continuous use in applications requiring uninterrupted service at full power. This rating is
an ISO 3046 standard power rating.