This document provides instructions for building a simple plastic handpump out of PVC pipes and fittings. The pump is capable of pumping water from at least 50 feet deep and works by using a piston and check valve mechanism. Key components include a 11⁄4 inch PVC pipe for the outer cylinder, a 3⁄4 inch nipple for the inner valve, and a piston made from cutting a 3⁄4 inch coupling in half. Assembly requires gluing pipes and fittings together and adding a bicycle inner tube and wood plug for seals.
This document provides instructions for building a simple plastic handpump out of PVC pipes and fittings. The pump is capable of pumping water from at least 50 feet deep and works by using a piston and check valve mechanism. Key components include a 11⁄4 inch PVC pipe for the outer cylinder, a 3⁄4 inch nipple for the inner valve, and a piston made from cutting a 3⁄4 inch coupling in half. Assembly requires gluing pipes and fittings together and adding a bicycle inner tube and wood plug for seals.
This document provides instructions for building a simple plastic handpump out of PVC pipes and fittings. The pump is capable of pumping water from at least 50 feet deep and works by using a piston and check valve mechanism. Key components include a 11⁄4 inch PVC pipe for the outer cylinder, a 3⁄4 inch nipple for the inner valve, and a piston made from cutting a 3⁄4 inch coupling in half. Assembly requires gluing pipes and fittings together and adding a bicycle inner tube and wood plug for seals.
(may be made from 8" This pump is good for at least nipple cut in half) 50 feet. The inner valve must ½" threaded tee be submerged for it to work, so the inner pipe must be al- most as long as the outer. All pipes/fittings are Schedule 40. 1¼"x¾" PVC The footvalve and wood plug reducer bushing may be inserted easily by first (not glued in) heating (not burning!) their respective pipes until soft. The 1¼" PVC tee ½" PVC pipe bicycle inner tube must cover all the holes in the ¾" nipple and be clamped at the lower end with the copper wire. Two 1¼" PVC pipe - pistons may be made from one water outlet ¾" coupling by cutting it in 1¼" PVC pipe half. Because of the small gap between piston and pipe, this pump will not work well with sandy water. Reducer bushing may be removed to disassemble pump. A screen may be added at the pump inlet to prevent trash from entering.
¾"x6" PVC nipple
threaded on at least the lower end. Has Small hole for the screw (below). ¼" holes drilled thru its middle part (no sharp edges) and Wood plug to press into ¾" nipple another small hole (end of mop handle or similar). for the screw. Screw to join ¾" nipple and ½" pipe. Length of bicycle inner tube - snug fit Circle of thick inner over ¾" pipe. tube rubber Small brass 11/8" diam. with Length of #14 copper wire woodscrew- a small hole for to tie around lower part of not too tight. the screw. inner tube as a clamp. Cylindrical block of wood slightly larger The piston - fits closely in the 1¼" pipe. than 1¼" diameter with ¼" holes drilled Consists of a ¾" threaded PVC coupling beveled through in this pattern: inside the lower edge. This should not be This is the footvalve. The able to touch the footvalve. File off any ridges. black dot is a hole for the screw.