Technical Data Sheet
Page tot
OLDOPAL®-DMA-
Accelerator 10%
Prod. No. 742-0060
Characteristics OLDOPAL-DMA-Accelerator 10% is a polymerisation accelerator on a dimethyl aniline
Application
Attention!
Properties in the.
Packaged state
base dissolved in styrene that is used to cure unsaturated polyester and vinyl estoy
resins,
on Satelerator is used to cure UP and VE resins in connection with benzoyl peroxide at
temperatures between 10°C and room temperalure. The reaction kicks off even at
To.avold undercuring, tis generally recommended to use at least 1% DMA Accelerator.
mea, goltme should not be controlled by the quantly of accelerator but by the type of
cvelerator selected:
DEA~Acceleraior >> jong gel times
DMA-Acceleralor >> medium gel tmes
DMPT-Accelerator >> short gel times
Cures with amine acoslerators and benzoy! peroxide result in poor outdoor weathering
Properties and lead to premature yellowing of the cured resin. Overfeeding with amine
‘eerators & 4%) may lead to abnormal curing. The desired cured resin propertioe wil
then not be achieved (¢.g. as a result of undercuring)
Property Test method Value
Density at20°C DINGS 2172 Toil
napNapenn
6mm diameter DINS3 211 5-7 seo,
Flash point DIN 53.213 arc
Reactivity:
BUFA method based on DIN 169456221
(100 g Palatal A 400-01 + 1 ml 742-0060 OLDOPAL-DMA-
Accelerator 10% + 3 g Lucidol CH 50 X)
20-30°C 18.22 min,
20°C - Tmax 22-30 min.
Tmax 180-200°C.‘OLDOPAL-ONA-
Accelerator 10%
Page 2 of?
Attention!
‘Storage/Handling
Attention!
‘The information given above refers exclusively to the use of the catalyst named and
quantity specified, The use of citferent products or differing quantities ofthe catalyst
may yield different results,
This product must be stored coo! in closed containers, protected from sunlight. Sheif-ife
's at least 3 months in unopened, original containers at a temperature of up to 20°C, Gal
‘and curing time may change affer extended periods of storage.
Never mix the accelerator directly with peroxide since this may cause explosive
decomposition of the peroxides!
‘Always mix the accelerator with the resin thoroughly first before adding the peroxide!
Nolo: The lncrmetion given above is based on our current state of knowledge ane exsetence. In View ofthe many factors thet may infuonce
‘iting condos ard appleaton. tho users net roeved fom caring out his cn tota and expermanta, No tepaly ncn weneney