Professional Documents
Culture Documents
Bonnetlifters
Bonnetlifters
Bonnetlifters
Fit Bonnet
Bonnet Lifters
Astra-Sport Disclaimer - Please note that this is a guide only and Astra-Sport take NO responsibility for
any damaged caused to yourself or vehicle whilst using this guide. If you are unsure how to do
something leave it to the professionals. Your Insurance and warranty might be invalidated if this
modification is done.
Step 1
Check all the parts are included in the package, and then screw the sockets to the end of the struts.
Step 2
Note: one lifter is not strong enough to support the
Note
bonnet on its own, so you must keep the original
stay in place until both sides are completed
…and fit the top mounting to the bonnet – on the MK3, the
mount simply replaces the original bolt (below), whereas on
the MK4 you’ll need to use the supplied bracket (as shown
right), and then replace the bolt.
Step 4
Fit the lower mount to the wing…
MK4’s - Fix the mounting to the hole in the front wing and
tighten up the nut from underneath. As the hole is quite
large it is wise to add some support to the mounting with
some cut-down ‘repair washers’, top and bottom as shown
left. These can be painted to ‘hide’ them.
Step 6
Fit the retaining clips to each joint – they slide in through the
small hole in the socket and then clip into the groove.
Once both sides are done, carefully lower the bonnet and
check the clearance to ensure that they are not catching
anywhere.