This document outlines the steps for performing nodal analysis on circuits containing transient elements like capacitors and inductors. The steps are:
1. Label all nodes and elements and write KCL equations for each node in terms of node voltages.
2. For circuits with capacitors or inductors, solve the KCL equations to find the initial conditions for the voltage or current through those elements at time t=0.
3. Replace capacitors and inductors with voltage and current sources respectively using their definitions and solve the modified circuit.
This document outlines the steps for performing nodal analysis on circuits containing transient elements like capacitors and inductors. The steps are:
1. Label all nodes and elements and write KCL equations for each node in terms of node voltages.
2. For circuits with capacitors or inductors, solve the KCL equations to find the initial conditions for the voltage or current through those elements at time t=0.
3. Replace capacitors and inductors with voltage and current sources respectively using their definitions and solve the modified circuit.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as DOCX, PDF, TXT or read online from Scribd
This document outlines the steps for performing nodal analysis on circuits containing transient elements like capacitors and inductors. The steps are:
1. Label all nodes and elements and write KCL equations for each node in terms of node voltages.
2. For circuits with capacitors or inductors, solve the KCL equations to find the initial conditions for the voltage or current through those elements at time t=0.
3. Replace capacitors and inductors with voltage and current sources respectively using their definitions and solve the modified circuit.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as DOCX, PDF, TXT or read online from Scribd
at each node in terms of node voltage Transients: Capacitors 1. Solve for voltage or current thru Cap or Inductors Ind Opp of resistor like resistor 2. Find initial cond. of element at t = 0 – Ic = c*dv/dt VL = L*di/dt - open capacitor, short inductor, find Vc(0 - ) Vc = v(t0) +1/c∫idt [t –t0] iL = i(to) 3. Replace storage element with V source +1/L∫vdt[t-t0] and flip sw Wc = ½ cv2 WL = 4 . at t = inf, find Vc or IL ½ Li2 5. Find T = RthC = L/RTh k1 + k2 = V(0+) V(inf) = k1 Vo(t) = k1 + k2e-t/T Amps 1. Solve for V+ first. 2. Write KCL eqn at – input and solve for V0 3. Ohm’s law for I0, KCL for I1 - If there is a cap. instead of resistor use ic = c*dv/dt