Professional Documents
Culture Documents
Tutorial Lesson 4 - Section Domes
Tutorial Lesson 4 - Section Domes
** For reasons of illustration and to facilitate these tutorial datum-curves have been prepared in the
models for this section. Datum-curves are not necessary to create these features. **
** You should now see the model as shown in the following image. **
** Select the bottom for the sketching plane and the front face for the “TOP” sketching reference. **
SCREEN: Select the Bottom Face as the Sketching Plane, #Okay, #Default
SKETCH Menu: #Edge, #Use
** Select the appropriate datum-curve entities, click check mark to complete sketch. **
** Select the right-side face for the sketching plane and the front face for the “TOP” sketching reference.
**
Points of note:
The sketches do not need to intersect.
Section and profile sketches must be perpendicular.
Sketches must be open-section.
The dome is applied to the entire selected surface.
The resultant surface is a mathematical average between the profile and section
sketches.