Professional Documents
Culture Documents
Product Resets: Restore The Factory-Set Defaults
Product Resets: Restore The Factory-Set Defaults
The product resets—Restore defaults and the NVRAM initialization—perform the same function. If
possible, use the Restore defaults function in the Service menu. If that menu is not accessible, use
the NVRAM sequence.
CAUTION: All onboard network settings are also reset. Be sure to print a configuration page before
restoring defaults. Make note of the IP address that is listed on the Jetdirect configuration page. You
might need to restore the IP address after restoring the defaults.
2. Use the arrow buttons to select Service, and then press OK.
3. Use the arrow buttons to select Restore defaults, and then press OK.
NVRAM initialization
Performing an NVRAM initialization resets the following settings and information:
CAUTION: All onboard network settings are also reset. Be sure to print a configuration page before
restoring defaults. Make note of the IP address that is listed on the Jetdirect configuration page. You
might need to restore the IP address after an NVRAM initialization.
After performing an NVRAM initialization, reconfigure any computers that print to this product. Uninstall
and then reinstall the product software on the computers.
2. Simultaneously press the right arrow button and the Cancel button . Hold these buttons as
you turn the product on.
3. When Permanent storage init. appears on the display, release both buttons.
When the product has finished the NVRAM initialization, it returns to the Ready state.