The document outlines steps in an experiment where the RMS AC voltage on the secondary side was measured to be 16.35V in step 3 and 16.1V in step 4a. Step 4b identifies channel 3 as measuring ripple voltage. Steps 5a and 5b discuss measurements taken with ripple. Step 6 then measures the RMS AC voltage on the secondary side under varying resistive loads between 25-250 ohms in 50 ohm increments.
The document outlines steps in an experiment where the RMS AC voltage on the secondary side was measured to be 16.35V in step 3 and 16.1V in step 4a. Step 4b identifies channel 3 as measuring ripple voltage. Steps 5a and 5b discuss measurements taken with ripple. Step 6 then measures the RMS AC voltage on the secondary side under varying resistive loads between 25-250 ohms in 50 ohm increments.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as DOCX, PDF, TXT or read online from Scribd
The document outlines steps in an experiment where the RMS AC voltage on the secondary side was measured to be 16.35V in step 3 and 16.1V in step 4a. Step 4b identifies channel 3 as measuring ripple voltage. Steps 5a and 5b discuss measurements taken with ripple. Step 6 then measures the RMS AC voltage on the secondary side under varying resistive loads between 25-250 ohms in 50 ohm increments.
Copyright:
Attribution Non-Commercial (BY-NC)
Available Formats
Download as DOCX, PDF, TXT or read online from Scribd