Professional Documents
Culture Documents
Infinitum
Infinitum
Infinitum combines two dynamos or alternators by their solenoids, using an axle, set like a centrifuge. The axle
has a ball at its center; the ball is placed within a ball and socket joint. The permanent magnets casings form
half of the ball and socket joint. The joint serves as a pivot for the axle, and the joint readily vibrates by virtue
of its attached springs and its material make up and structure.
OR
-within a clear colorless glass bulb; (with-perhaps-fluid conduits to convey the noble gas Or gases out of and in
to the bulb, to and fro a dedicated heat exchange region)…
Infinitum OPERATION
Begins with-
Mechanical energy-INPUT-Once-
-In the form of the VIBRATION and thus Relative MOTION of the Permanent Magnets Casings, and
consequently the VIBRATION of the Ball and Sockets Joint occurs, and very importantly, the VIBRATION of
the Permanent Magnets occurs simultaneously;
Which CONTINUES
-In the form of Magnetic energy –output and or –influence, as Magnetic energy field flux;
-Which causes Thermal energy output as Eddy currents INDUCTION in the Solenoids Coils or Conductor(s)
does occur- due to the Magnetic energy field Flux;
-Which causes Mechanical energy output as the ROTATION of the Solenoids occurs [with the Solenoids Coils
or Conductor(s) experiencing the Magnetic energy field Flux];
-Which causes Mechanical energy influence as the consequent centrifugal ROTATION of the Axle connecting
and connected to the Solenoids; being the same as the Axle Ball Center ROTATION within the Ball and Socket
Joint.
-Which causes Mechanical energy influence as the VIBRATION of the Ball and Socket Joint, and consequently
the VIBRATION of the Permanent Magnets Casings occurs, and very importantly the VIBRATION of the
Permanent Magnets occurs simultaneously;
*As such the OPERATION becomes and remains a self repeating CYCLE or PROCESS that includes its
‘INPUT’, thus LOOPING back to the Beginning and Continuing.
**Meanwhile
-Electrical energy output occurs as Electric current(s) INDUCTION in the Solenoids Coils or Conductor(s)
during the Solenoids ROTATION between the Permanent Magnets; the Electric current is conveyed to
wherever needed with wires, brushes and commutator (of split copper rings or slip copper rings) connected to
the Solenoids; which causes-
-Visual or Light energy output, as the current carrying Solenoids Coils or Conductor(s), being naked, are in
contact with the Chemical energy of the Noble gas or gases
*The Thermal energy –output and or –influence converts to Electrical energy, by means of Thermopiles close
by, or in another region to and from which the fluid conduits may convey the Noble gas or gases that may serve
as Thermal energy or Heat Exchange Fluid;
*The Visual or Light energy converts to Electrical energy by means of ‘Solar Cells’ or Photo-sensitive and –
Photo-responsive/reactive diodes…
**With the Electrical energy output flowing through wires made into coils and naked perhaps, Magnets may be
mass produced by inserting desired and applicable shapes of steel ‘bars or blocks’, for making more Infinitum
and for replacing Infinitum Magnets.
****Infinitum would also work better and more efficiently around places like bridges, anywhere there is heavy
traffic, on the seas, taking advantage of ambient vibration to aid perpetual operation****
KEY (to make sense of the diagram following in the next page):